[Federal Register: November 14, 2003 (Volume 68, Number 220)]
[Rules and Regulations]
[Page 64537-64540]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr14no03-17]
-----------------------------------------------------------------------
ENVIRONMENTAL PROTECTION AGENCY
40 CFR Part 52
[CA261-0420a; FRL-7582-2]
Revisions to the California State Implementation Plan, San Diego
County Air Pollution Control District; San Joaquin Valley Unified Air
Pollution Control District
AGENCY: Environmental Protection Agency (EPA).
ACTION: Direct final rule.
-----------------------------------------------------------------------
SUMMARY: EPA is taking direct final action to approve revisions to the
San Diego County Air Pollution Control District (SDCAPCD) and San
Joaquin Valley Unified Air Pollution Control District (SJVUAPCD)
portions of the California State Implementation Plan (SIP). These
revisions concern volatile organic compound (VOC) emissions from the
metal parts and aerospace coating industries. We are approving local
rules that regulate these emission sources under the Clean Air Act as
amended in 1990 (CAA or the Act).
DATES: This rule is effective on January 13, 2004 without further
notice, unless EPA receives adverse comments by
[[Page 64538]]
December 15, 2003. If we receive such comment, we will publish a timely
withdrawal in the Federal Register to notify the public that this rule
will not take effect.
ADDRESSES: Send comments to Andy Steckel, Rulemaking Office Chief (AIR-
4), U.S. Environmental Protection Agency, Region IX, 75 Hawthorne
http://www.regulations.gov.
You can inspect copies of the submitted SIP revisions, EPA's
technical support documents (TSDs), and public comments at our Region
IX office during normal business hours by appointment. You may also see
copies of the submitted SIP revisions by appointment at the following
locations:
Air and Radiation Docket and Information Center, U.S.
Environmental Protection Agency, Room B-102, 1301 Constitution
Avenue, NW., (Mail Code 6102T), Washington, DC 20460;
California Air Resources Board, Stationary Source Division, Rule
Evaluation Section, 1001 ``I'' Street, Sacramento, CA 95814;
San Diego County Air Pollution Control District, 9150 Chesapeake
Drive, San Diego, CA 92123;
San Joaquin Valley Unified Air Pollution Control District, 1990
East Gettysburg Street, Fresno, CA, 93726.
A copy of the rule may also be available via the Internet at http://www.arb.ca.gov/drdb/drdbltxt.htm.
Please be advised that this is not
an EPA website and may not contain the same version of the rule that
was submitted to EPA.
FOR FURTHER INFORMATION CONTACT: Jerald S. Wamsley, EPA Region IX, at either (415) 947-4111, or wamsley.jerry@epa.gov.
SUPPLEMENTARY INFORMATION: Throughout this document, ``we,'' ``us'' and
``our'' refer to EPA.
Table of Contents.
I. The State's Submittal
A. What Rules did the State submit?
B. Are there other versions of these rules?
C. What is the purpose of the rule revisions?
II. EPA's Evaluation and Action
A. How is EPA evaluating the rules?
B. Do the rules meet the evaluation criteria?
C. EPA recommendations to further improve the rules.
D. Public comment and final action
III. Statutory and Executive Order Reviews
I. The State's Submittal
A. What Rules Did the State Submit?
Table 1 lists the rules we are approving with the dates that they
were adopted by the local air agencies and submitted by the California
Air Resources Board (CARB).
Table 1.--Submitted Rules
----------------------------------------------------------------------------------------------------------------
Rule Rule title Adopted Submitted
----------------------------------------------------------------------------------------------------------------
SDCAPCD..................... 67.3 Metal Parts and Products...... 04/09/03 06/05/03
SJVUAPCD.................... 4605 Aerospace Assembly and 12/20/01 02/20/02
Component Coating Operations.
----------------------------------------------------------------------------------------------------------------
On July 18, 2003 for SDCAPCD Rule 67.3 and March 15, 2002 for
SJVUAPCD Rule 4605, EPA found these rule submittals met the
completeness criteria in 40 CFR Part 51 Appendix V.
B. Are There Other Versions of These Rules?
We approved a version of SDCAPCD Rule 67.3 into the SIP on March
27, 1997 (see 62 Federal Register (FR) 14639). Similarly, we approved a
version of SJVUAPCD Rule 4605 into the SIP on August 17, 1998 (see 63
FR 43884). Between these SIP incorporations and today, CARB has made no
intervening submittals of these two rules.
C. What Is The Purpose of the Submitted Rule Revisions?
VOCs help produce ground-level ozone and smog, which harm human
health and the environment. Section 110(a) of the CAA requires states
to submit regulations that control VOC emissions.
SDCAQMD Rule 67.3 is designed to reduce volatile organic compound
(VOC) emissions at industrial sites engaged in metal parts and product
coating operations. VOCs are emitted during the preparation and coating
of the metal parts and products, as well as the drying phase of the
coating process. Rule 67.3 establishes general emission limits in units
of pound of VOC per gallon of coating (lb/gal), and grams of VOC per
litre (gr/1) of coating, less water and exempt compounds as applied.
Also, the rule allows the use of add-on emission controls whose
combined capture and control efficiency must be 85 percent or better
and specifies certain operating equipment. The rule also contains
provisions for appropriate methods of analysis, exemptions, alternative
emission control plans (pursuant to Rule 67.1), record keeping, and
emission reduction credits.
SDCAPCD's April 9, 2003 amendments to Rule 67.3 included these
significant changes to the May 15, 1996 adopted version within the SIP.
--An exemption was added for specialty sign painting and construction.
--The VOC content definition was deleted and referenced to Rule 2,
Subsection (b)(52).
SJVUAPCD Rule 4605 is designed to reduce volatile organic compound
(VOC) emissions at industrial sites engaged in manufacturing,
assembling, coating, masking, bonding, paint stripping, surface
cleaning, service, and maintenance of aerospace components. VOCs are
emitted during the preparation, coating, and drying phase of any of the
above listed processes. Rule 4605 establishes general emission limits
of VOC per liter of coating less water and exempt compounds as applied.
It also allows for the use of add-on emission controls with a combined
capture/control efficiency of approximately 81 percent.
SJVUAPCD's December 20, 2001 amendments to Rule 4605 included the
following significant changes to its 1998 SIP-limited approved/
disapproved version.
--The rule's purpose and applicability statements were changed to
include organic solvent cleaning as well as the storage and disposal of
organic solvents and waste solvent materials derived from coating
operations subject to the rule. The majority of changes to the rule
stem from adding organic solvent use, disposal, and storage
requirements to the rule.
--Eleven new definitions were added to the rule to support the new rule
amendments.
--In Table 1, May 1, 2002 emission limits are delayed until May 1,
2003. However, this change affects only Adhesive Bonding Primer
requirements. Adhesive Bonding Primer requirements are amended
beginning May 1, 2003. First, several sub-categories are deleted and
[[Page 64539]]
renamed reducing them from 8 to 6. Of these renamed subcategories of
Adhesive Bonding Primer, All Military Aircraft, Remanufactured
Commercial Aircraft Parts, and Sonic and Acoustic Applications are
given a content requirement of 805 grams per liter (gr/l) where they
had been assigned requirement of 250 gr/l.
--A requirement for enclosed equipment cleaning is added at Section
5.2.3.
--High Volume Low Pressure spray application requirements were defined
at Section 5.5.3.
--Records must be retained for 5 years.
The respective TSD each rule has more information about each rule
and its revisions.
II. EPA's Evaluation and Action
A. How Is EPA Evaluating the Rules?
Generally, SIP rules must be enforceable (see section 110(a) of the
Act), must require Reasonably Available Control Technology (RACT) for
major sources in nonattainment areas (see section 182(a)(2)(A)), and
must not relax existing requirements (see sections 110(l) and 193).
Both the SDCAPCD and SJVUAPCD regulate an ozone nonattainment area (see
40 CFR part 81), so each rule must fulfill RACT.
Guidance and policy documents that we used to help evaluate
specific enforceability and RACT requirements consistently include the
following:
1. Portions of the proposed post-1987 ozone and carbon monoxide
policy that concern RACT, 52 FR 45044, November 24, 1987;
2. ``Issues Relating to VOC Regulation Cutpoints, Deficiencies, and
Deviations,'' EPA, May 25, 1988 (the Bluebook);
3. ``Guidance Document for Correcting Common VOC & Other Rule
Deficiencies,'' EPA Region 9, August 21, 2001 (the Little Bluebook);
4. ``Control of Volatile Organic Emissions from Existing Stationary
Sources Volume VI: Surface Coating of Miscellaneous Metal Parts and
Products,'' USEPA, June 1978, EPA-450/2-78-015; and,
5. ``Control of Volatile Organic Emissions from Coating Operations
at Aerospace Manufacturing and Rework Operations,'' USEPA, 1997, EPA-
453/R-97-004.
B. Do the Rules Meet the Evaluation Criteria?
We believe these rules are consistent with the relevant policy and
guidance regarding enforceability, RACT, and SIP relaxations. While the
revisions to SDCAPCD Rule 67.3 and SJVUAPCD Rule 4605 contain specific
rule relaxations, SDCAPCD and SJVUAPCD have provided analyses
demonstrating that the added emissions resulting from these rule
relaxations are either a de minimis amount in the case of SDCAPCD Rule
67.3, or offset by emission reductions elsewhere in the case of
SJVUAPCD Rule 4605. Given these analyses, we find that neither
reasonable further progress towards, nor achievement of the air quality
standards will be jeopardized.
The respective TSD for each rule has more detailed information on
these analyses and our evaluation.
C. EPA Recommendations To Further Improve the Rules
We have no additional rule revisions that do not affect EPA's
current action, but are recommended for the next time the local agency
modifies the rules.
D. Public Comment and Final Action
As authorized in section 110(k)(3) of the Act, EPA is fully
approving the submitted rules because we believe they fulfill all
relevant requirements. We do not think anyone will object to this
approval, so we are finalizing it without proposing it in advance.
However, in the Proposed Rules section of this Federal Register, we are
simultaneously proposing approval of the same submitted rules. If we
receive adverse comments by December 15, 2003, we will publish a timely
withdrawal in the Federal Register to notify the public that the direct
final approval will not take effect and we will address the comments in
a subsequent final action based on the proposal. If we do not receive
timely adverse comments, the direct final approval will be effective
without further notice on January 13, 2004. This will incorporate these
rules into the federally enforceable SIP.
Please note that if EPA receives adverse comment on an amendment,
paragraph, or section of this rule and if that provision may be severed
from the remainder of the rule, EPA may adopt as final those provisions
of the rule that are not the subject of an adverse comment.
III. Statutory and Executive Order Reviews
Under Executive Order 12866 (58 FR 51735, October 4, 1993), this
action is not a ``significant regulatory action'' and therefore is not
subject to review by the Office of Management and Budget. For this
reason, this action is also not subject to Executive Order 13211,
``Actions Concerning Regulations That Significantly Affect Energy
Supply, Distribution, or Use'' (66 FR 28355, May 22, 2001). This action
merely approves state law as meeting Federal requirements and imposes
no additional requirements beyond those imposed by state law.
Accordingly, the Administrator certifies that this rule will not have a
significant economic impact on a substantial number of small entities
under the Regulatory Flexibility Act (5 U.S.C. 601 et seq.). Because
this rule approves pre-existing requirements under state law and does
not impose any additional enforceable duty beyond that required by
state law, it does not contain any unfunded mandate or significantly or
uniquely affect small governments, as described in the Unfunded
Mandates Reform Act of 1995 (Pub. L. 104-4).
This rule also does not have tribal implications because it will
not have a substantial direct effect on one or more Indian tribes, on
the relationship between the Federal Government and Indian tribes, or
on the distribution of power and responsibilities between the Federal
Government and Indian tribes, as specified by Executive Order 13175 (65
FR 67249, November 9, 2000). This action also does not have Federalism
implications because it does not have substantial direct effects on the
States, on the relationship between the national government and the
States, or on the distribution of power and responsibilities among the
various levels of government, as specified in Executive Order 13132 (64
FR 43255, August 10, 1999). This action merely approves a state rule
implementing a Federal standard, and does not alter the relationship or
the distribution of power and responsibilities established in the Clean
Air Act. This rule also is not subject to Executive Order 13045
``Protection of Children from Environmental Health Risks and Safety
Risks'' (62 FR 19885, April 23, 1997), because it is not economically
significant.
In reviewing SIP submissions, EPA's role is to approve state
choices, provided that they meet the criteria of the Clean Air Act. In
this context, in the absence of a prior existing requirement for the
State to use voluntary consensus standards (VCS), EPA has no authority
to disapprove a SIP submission for failure to use VCS. It would thus be
inconsistent with applicable law for EPA, when it reviews a SIP
submission, to use VCS in place of a SIP submission that otherwise
satisfies the provisions of the Clean Air Act. Thus, the requirements
of section 12(d) of the National Technology Transfer and Advancement
Act of 1995 (15 U.S.C. 272 note) do not apply. This rule does not
impose an information collection
[[Page 64540]]
burden under the provisions of the Paperwork Reduction Act of 1995 (44
U.S.C. 3501 et seq.).
The Congressional Review Act, 5 U.S.C. section 801 et seq., as
added by the Small Business Regulatory Enforcement Fairness Act of
1996, generally provides that before a rule may take effect, the agency
promulgating the rule must submit a rule report, which includes a copy
of the rule, to each House of the Congress and to the Comptroller
General of the United States. EPA will submit a report containing this
rule and other required information to the U.S. Senate, the U.S. House
of Representatives, and the Comptroller General of the United States
prior to publication of the rule in the Federal Register. A major rule
cannot take effect until 60 days after it is published in the Federal
Register. This action is not a ``major rule'' as defined by 5 U.S.C.
section 804(2).
Under section 307(b)(1) of the Clean Air Act, petitions for
judicial review of this action must be filed in the United States Court
of Appeals for the appropriate circuit by January 13, 2004. Filing a
petition for reconsideration by the Administrator of this final rule
does not affect the finality of this rule for the purposes of judicial
review nor does it extend the time within which a petition for judicial
review may be filed, and shall not postpone the effectiveness of such
rule or action. This action may not be challenged later in proceedings
to enforce its requirements. (See section 307(b)(2).)
List of Subjects in 40 CFR Part 52
Environmental protection, Air pollution control, Incorporation by
reference, Intergovernmental relations, Ozone, Reporting and
recordkeeping requirements, Volatile organic compounds.
Dated: October 16, 2003.
Debra Jordan,
Acting Regional Administrator, Region IX.
0
Part 52, chapter I, title 40 of the Code of Federal Regulations is
amended as follows:
PART 52--[AMENDED]
0
1. The authority citation for Part 52 continues to read as follows:
Authority: 42 U.S.C. 7401 et seq.
Subpart F--California
0
2. Section 52.220 is amended by adding paragraphs (c)(294)(i)(A)(5) and
(c)(316)(i)(C) to read as follows:
Sec. 52.220 Identification of plan.
* * * * *
(c) * * *
(294) * * *
(i) * * *
(A) * * *
(5) Rule 4605 adopted on December 19, 1991 and amended on December
20, 2001.
* * * * *
(316) * * *
(i) * * *
(C) San Diego County Air Pollution Control District.
(1) Rule 67.3 adopted on May 9, 1979 and amended on April 9, 2003.
* * * * *
[FR Doc. 03-28305 Filed 11-13-03; 8:45 am]
BILLING CODE 6560-50-P