[Federal Register: August 16, 2005 (Volume 70, Number 157)]
[Proposed Rules]
[Page 48084-48085]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr16au05-10]
=======================================================================
-----------------------------------------------------------------------
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 39
[Docket No. 2003-NE-31-AD]
Airworthiness Directives: Rolls-Royce plc RB211-535 Turbofan
Engines
AGENCY: Federal Aviation Administration, DOT.
ACTION: Proposed rule; withdrawal.
-----------------------------------------------------------------------
SUMMARY: The FAA is withdrawing a notice of proposed rulemaking (NPRM).
That NPRM proposed a new airworthiness directive (AD) that applies to
certain Rolls-Royce plc (RR) models RB211-535C-37, RB211-535E4-37,
RB211-535E4-B-37, and RB211-535E4-B-75 turbofan engines. The NPRM had
applied to those engines with radial drive steady bearing part number
(P/N) LK76084 installed, with fewer than 3,000 engine operating hours
on the bearing. That proposed action would have required initial and
repetitive visual inspections of the engine oil scavenge filter for
evidence of radial drive steady bearing failure. If after finding
evidence, the proposed action would have required a visual inspection
of the radial drive steady bearing for damage and evidence of bearing
debris. Since we issued that NPRM, RR notified us that all at-risk
radial drive steady bearings are removed from service. RR also notified
us that remaining bearings in service are now well over the 3,000-
engine-operating-hour threshold and are no longer at risk. Accordingly,
we withdraw the proposed rule.
FOR FURTHER INFORMATION CONTACT: Ian Dargin, Aerospace Engineer, Engine
Certification Office, FAA, Engine and Propeller Directorate, 12 New
England Executive Park, Burlington, MA 01803-5299; telephone (781) 238-
7178; fax (781) 238-7199.
SUPPLEMENTARY INFORMATION: The FAA proposed to amend 14 CFR part 39
with a proposed airworthiness directive (AD). The proposed AD applies
to Rolls-Royce plc (RR) models RB211-535C-37, RB211-535E4-37, RB211-
535E4-B-37, and RB211-535E4-B-75 turbofan engines. The proposed AD
would have applied to those engines with radial drive steady bearing,
P/N LK76084 installed, with fewer than 3,000 engine-operating-hours on
the bearing. We published the proposed AD in the Federal Register on
October 9, 2003, (68 FR 58291). That proposed action would have
required initial and repetitive visual inspections of the engine oil
scavenge filter for evidence of radial drive steady bearing failure. If
evidence was found, that proposed action would have required a visual
inspection of the radial drive steady bearing for damage and evidence
of bearing debris. That proposed action was prompted by notification
from the Civil Aviation Authority (CAA), which is the airworthiness
authority for the U.K. The CAA notified us that an unsafe condition may
exist on RR models RB211-535C-37, RB211-535E4-37, RB211-535E4-B-37, and
RB211-535E4-B-75 turbofan engines. The unsafe condition had applied to
those engines with radial drive steady bearing P/N LK76084 installed
with fewer than 3,000 engine operating hours on the bearing. The CAA
received reports of seven low time failures of radial drive steady
bearings within a four-month period. These failures were not detected
through routine magnetic chip detector monitoring because the failed
bronze bearing cages are nonmagnetic, and the cage failure mode is
rapid. The proposed actions intended to prevent a possible dual-engine
in-flight shutdown caused by radial drive steady bearing failure.
Since the issuance of that NPRM, RR notified us that all at-risk
radial drive steady bearings are removed from service. RR also notified
us that the remaining bearings in service are now well over the 3,000-
engine-operating-hour threshold and are no longer at risk.
Upon further consideration, we hereby withdraw the proposed rule
for the following reasons:
After RR notifying us of the removal from service and
bearing threshold information, stated previously.
[[Page 48085]]
AD 2000-09-14 (65 FR 30527, May 12, 2000) and AD 2001-19-
05 (66 FR 49099, September 26, 2001) currently address the same radial
drive steady bearing, P/N LK76084.
AD 2000-09-14 and AD 2001-19-05 mandate replacing low-time
bearings that are at risk.
Withdrawal of this notice of proposed rulemaking constitutes only
such action, and does not preclude the agency from issuing another
notice in the future, nor does it commit the agency to any course of
action in the future.
Since this action only withdraws a notice of proposed rulemaking,
it is neither a proposed nor a final rule. Therefore, Executive Order
12866, the Regulatory Flexibility Act, or DOT Regulatory Policies and
Procedures (44 FR 11034, February 26, 1979) do not cover this
withdrawal.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
The Withdrawal
Accordingly, the notice of proposed rulemaking, Docket 2003-NE-31-
AD, published in the Federal Register on October 9, 2003, (68 FR
58291), is withdrawn.
Issued in Burlington, Massachusetts, on August 9, 2005.
Francis A. Favara,
Acting Manager, Engine and Propeller Directorate, Aircraft
Certification Service.
[FR Doc. 05-16167 Filed 8-15-05; 8:45 am]
BILLING CODE 4910-13-P