[Federal Register: December 19, 2006 (Volume 71, Number 243)]
[Rules and Regulations]
[Page 75855-75857]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr19de06-3]
-----------------------------------------------------------------------
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 39
[Docket No. FAA-2006-26193; Directorate Identifier 2001-NE-01-AD;
Amendment 39-14853; AD 2006-25-12]
RIN 2120-AA64
Airworthiness Directives; Rolls-Royce Corporation 501-D Series
Turboprop Engines
AGENCY: Federal Aviation Administration (FAA), Department of
Transportation (DOT).
ACTION: Final rule.
-----------------------------------------------------------------------
SUMMARY: The FAA is superseding an existing airworthiness directive
(AD) for Rolls-Royce Corporation (RRC) 501-D series turboprop engines.
That AD requires removal from service of certain turbine rotor
components at reduced life limits. This AD requires the same actions
but adds two new life limits. This AD results from RRC reevaluating and
revising component life limits for 501-D22 series turboprop engines. We
are issuing this AD to prevent uncontained turbine rotor failure
resulting in an in-flight engine shutdown and possible damage to the
airplane.
DATES: This AD becomes effective January 23, 2007. The Director of the
Federal Register approved the incorporation by reference of certain
publications listed in the regulations as of January 23, 2007.
ADDRESSES: You can get the service information identified in this AD
from Rolls-Royce Corporation, P.O. Box 420, 2001 South Tibbs Avenue,
Indianapolis, IN 46206-0420; telephone (317) 230-2000; fax (317) 230-
4020 for the service information identified in this AD.
You may examine the AD docket on the Internet at http://dms.dot.gov
or in Room PL-401 on the plaza level of the
[[Page 75856]]
Nassif Building, 400 Seventh Street, SW., Washington, DC.
FOR FURTHER INFORMATION CONTACT: Michael Downs, Aerospace Engineer,
Chicago Aircraft Certification Office, FAA, 2300 East Devon Avenue, Des
Plaines, IL 60018; telephone (847) 294-7870; fax (847) 294-7834.
SUPPLEMENTARY INFORMATION: The FAA proposed to amend 14 CFR part 39
with a proposed AD. The proposed AD applies to RRC 501-D series
turboprop engines. We published the proposed AD in the Federal Register
on February 22, 2006 (71 FR 9048). That action proposed to require
removal from service of certain turbine rotor components at reduced
life limits, the same as AD 2003-07-02, but would add two new life
limits.
Examining the AD Docket
You may examine the docket that contains the AD, any comments
received, and any final disposition in person at the Docket Management
Facility Docket Offices between 9 a.m. and 5 p.m., Monday through
Friday, except Federal holidays. The Docket Office (telephone (800)
647-5227) is located on the plaza level of the Department of
Transportation Nassif Building at the street address stated in
ADDRESSES. Comments will be available in the AD docket shortly after
the DMS receives them.
Comments
We provided the public the opportunity to participate in the
development of this AD. We received no comments on the proposal or on
the determination of the cost to the public.
Incorrect Supplemental Type Certificate (STC) Number
Since we issued the proposed AD, we became aware that the STC
number SE1161EA, referenced in paragraph (c), is incorrect. We
corrected the number to STC SA4-1100 in the AD.
Conclusion
We have carefully reviewed the available data and determined that
air safety and the public interest require adopting the AD with the
change described previously.
Costs of Compliance
We estimate that this AD will affect 684 engines installed on
aircraft of U.S. registry. The action does not impose any additional
labor costs if performed at the time of scheduled engine overhaul.
Required parts will cost about $45,000 per engine. Based on these
figures, we estimate the total cost of the AD to U.S. operators to be
$30,780,000.
Special Flight Permits Paragraph Removed
Paragraph (f) of the current AD, AD 2003-07-02, contains a
paragraph pertaining to special flight permits. Even though this AD
does not contain a similar paragraph, we have made no changes with
regard to the use of special flight permits to operate the airplane to
a repair facility to do the work required by this AD. In July 2002, we
published a new Part 39 that contains a general authority regarding
special flight permits and airworthiness directives; see Docket No. FAA
2004-8460, Amendment 39-9474 (69 FR 47998, July 22, 2002). Thus, when
we now supersede ADs we will not include a specific paragraph on
special flight permits unless we want to limit the use of that general
authority granted in section 39.23.
Docket Number Change
We are transferring the docket for this AD to the Docket Management
System as part of our on-going docket management consolidation efforts.
The new Docket No. is FAA-2006-26193. The old Docket No. became the
Directorate Identifier, which is 2001-NE-01-AD. This AD might get
logged into the DMS docket, ahead of the previously collected documents
from the old docket file, as we are in the process of sending those
items to the DMS.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to
issue rules on aviation safety. Subtitle I, Section 106, describes the
authority of the FAA Administrator. Subtitle VII, Aviation Programs,
describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in
Subtitle VII, Part A, Subpart III, Section 44701, ``General
requirements.'' Under that section, Congress charges the FAA with
promoting safe flight of civil aircraft in air commerce by prescribing
regulations for practices, methods, and procedures the Administrator
finds necessary for safety in air commerce. This regulation is within
the scope of that authority because it addresses an unsafe condition
that is likely to exist or develop on products identified in this
rulemaking action.
Regulatory Findings
We have determined that this AD will not have federalism
implications under Executive Order 13132. This AD will not have a
substantial direct effect on the States, on the relationship between
the national government and the States, or on the distribution of power
and responsibilities among the various levels of government.
For the reasons discussed above, I certify that this AD:
(1) Is not a ``significant regulatory action'' under Executive
Order 12866;
(2) Is not a ``significant rule'' under DOT Regulatory Policies and
Procedures (44 FR 11034, February 26, 1979); and
(3) Will not have a significant economic impact, positive or
negative, on a substantial number of small entities under the criteria
of the Regulatory Flexibility Act.
We prepared a summary of the costs to comply with this AD and
placed it in the AD Docket. You may get a copy of this summary at the
address listed under ADDRESSES.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Incorporation by
reference, Safety.
Adoption of the Amendment
0
Accordingly, under the authority delegated to me by the Administrator,
the Federal Aviation Administration amends 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
0
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
0
2. The FAA amends Sec. 39.13 by removing Amendment 39-13098 (68 FR
15937, April 2, 2003), and by adding a new airworthiness directive,
Amendment 39-14853, to read as follows:
2006-25-12 Rolls-Royce Corporation (formerly Allison Engine
Company): Amendment 39-14853. Docket No. FAA-2006-26193; Directorate
Identifier 2001-NE-01-AD.
Effective Date
(a) This airworthiness directive (AD) becomes effective January
23, 2007.
Affected ADs
(b) This AD supersedes AD 2003-07-02, Amendment 39-13098.
Applicability
(c) This AD applies to Rolls-Royce Corporation (formerly Allison
Engine Company) (RRC) 501-D series turboprop engines. These engines
are installed on, but not limited to, Lockheed 188 series and 382
series turboprop airplanes, Airbus 377SG5-F (Super Guppy) airplanes,
and Convair Models 340 and 440 airplanes which have RRC 501-D series
turboprop engines
[[Page 75857]]
installed under Supplemental Type Certificate No. SA4-1100. These
latter models are commonly referred to as Convair 580/580A or 5800
models.
(d) This AD results from RRC reevaluating and revising component
life limits for 501-D22 series turboprop engines. We are issuing
this AD to prevent uncontained turbine rotor failure resulting in an
in-flight engine shutdown and possible damage to the airplane.
Compliance
(e) You are responsible for having the actions required by this
AD performed within the compliance times specified unless the
actions have already been done.
501-D13 Series Engines
(f) For 501-D13 series engines, remove turbine wheels and
spacers from service as specified in the following Table 1:
Table 1.--501-D13 Series Life Limits
----------------------------------------------------------------------------------------------------------------
Life limit for wheels
that have complied with Life limit for wheels
commercial overhaul that have not complied
Part name Part No. information letter with COIL 401, dated
(COIL) 401, dated May May 1978
1978
----------------------------------------------------------------------------------------------------------------
(1) Second-stage turbine wheel 6847142 and 6876892.... Remove from service Remove from service
assembly. before or upon before or upon
accumulating 16,000 accumulating 12,000
cycles-in-service CIS.
(CIS).
(2) Third-stage turbine wheel 6845883 and 6849743.... Remove from service Remove from service
assembly. before or upon before or upon
accumulating 13,000 accumulating 10,000
CIS. CIS.
(3) Fourth-stage turbine wheel 6876468................ Remove from service Remove from service
assembly. before or upon before or upon
accumulating 24,000 accumulating 18,000
CIS. CIS.
----------------------------------------------------------------------------------------------------------------
501-D22 Series Engines
(g) For 501-D22 series engines, remove turbine wheels and
spacers from service as specified in the following Table 2:
Table 2.--501-D22 Series Life Limits
------------------------------------------------------------------------
Part name Part No. Remove from service
------------------------------------------------------------------------
(1) Third-stage turbine wheel 6855083.......... Before or upon
assembly. accumulating 10,000
cycles-in-service
(CIS).
(2) 1st-2nd-stage spacer 6844632, Before or upon
assembly. 23033463, accumulating 4,700
23064854, and CIS.
23064858.
(3) 1st-2nd-stage spacer 23056966......... (i) Before or upon
assembly. accumulating 8,000
CIS.
(ii) If the 1st-2nd-
stage spacer
assembly passes the
hardness criteria in
RRC Commercial
Engine Bulletin No.
CEB-A-72-1135,
Revision 2, dated
July 11, 2003, then
before or upon
accumulating 10,000
CIS.
(4) 2nd-3rd-stage spacer 23033456......... Before or upon
assembly. accumulating 4,200
CIS.
(5) 2nd-3rd-stage spacer 23033464 and Before or upon
assembly. 6842683. accumulating 5,200
CIS.
(6) 3rd-4th-stage spacer 6844794 prior to Before or upon
assembly. revision letter accumulating 5,100
``R''. CIS.
------------------------------------------------------------------------
Alternative Methods of Compliance
(h) The Manager, Chicago Aircraft Certification Office, has the
authority to approve alternative methods of compliance for this AD
if requested using the procedures found in 14 CFR 39.19.
Related Information
(i) Information on 501-D13 series engine turbine life limits can
be found in RRC Commercial Service Letter (CSL) No. CSL-120,
Revision No. 52, dated July 22, 2002.
(j) Information on 501-D22 series engine turbine life limits can
be found in RRC CSL No. CSL-1001, Revision No. 20, dated April 5,
2005.
Material Incorporated by Reference
(k) You must use Rolls-Royce Corporation Commercial Engine
Bulletin No. CEB-A-72-1135, Revision 2, dated July 11, 2003, to
check if 1st-2nd stage spacer assemblies pass the hardness criteria
required by Table 2 of this AD. The Director of the Federal Register
approved the incorporation by reference of this service bulletin in
accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Contact Rolls-
Royce Corporation, P.O. Box 420, 2001 South Tibbs Avenue,
Indianapolis, IN 46206-0420; telephone (317) 230-2000; fax (317)
230-4020 for a copy of this service information. You may review
copies at the National Archives and Records Administration (NARA).
For information on the availability of this material at NARA, call
202-741-6030, or go to: http://www.archives.gov/federal-register/cfr/ibr-locations.html
.
Issued in Burlington, Massachusetts, on December 11, 2006.
Peter A. White,
Acting Manager, Engine and Propeller Directorate, Aircraft
Certification Service.
[FR Doc. E6-21352 Filed 12-18-06; 8:45 am]
BILLING CODE 4910-13-P