[Federal Register: June 5, 2007 (Volume 72, Number 107)]
[Rules and Regulations]
[Page 30955-30956]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr05jn07-1]
========================================================================
Rules and Regulations
Federal Register
________________________________________________________________________
This section of the FEDERAL REGISTER contains regulatory documents
having general applicability and legal effect, most of which are keyed
to and codified in the Code of Federal Regulations, which is published
under 50 titles pursuant to 44 U.S.C. 1510.
The Code of Federal Regulations is sold by the Superintendent of Documents.
Prices of new books are listed in the first FEDERAL REGISTER issue of each
week.
========================================================================
[[Page 30955]]
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 39
[Docket No. FAA-2006-26585; Directorate Identifier 2006-NE-44-AD;
Amendment 39-15087; AD 2007-12-09]
RIN 2120-AA64
Airworthiness Directives; General Electric Company CF34-10E
Series Turbofan Engines
AGENCY: Federal Aviation Administration (FAA), Department of
Transportation (DOT).
ACTION: Final rule.
-----------------------------------------------------------------------
SUMMARY: The FAA is adopting a new airworthiness directive (AD) for
General Electric Company (GE) CF34-10E series turbofan engines. This AD
requires revising the combustor case published life limit and removing
combustor cases from service before reaching a reduced life limit. This
AD results from GE's evaluation of the effects to the combustor case
due to installing version 5.10 software in the full-authority digital
electronic control (FADEC), and revising the combustor case published
life limit. We are issuing this AD to prevent uncontained combustor
case failure resulting in an in-flight engine shutdown and possible
damage to the airplane.
DATES: This AD becomes effective July 10, 2007.
ADDRESSES: You may examine the AD docket on the Internet at http://dms.dot.gov
or in Room PL-401 on the plaza level of the Nassif
Building, 400 Seventh Street, SW., Washington, DC.
FOR FURTHER INFORMATION CONTACT: Tara Chaidez, Aerospace Engineer,
Engine Certification Office, FAA, Engine & Propeller Directorate, 12
New England Executive Park, Burlington, MA 01803; e-mail:
tara.chaidez@faa.gov; telephone (781) 238-7773; fax (781) 238-7199.
SUPPLEMENTARY INFORMATION: The FAA proposed to amend 14 CFR part 39
with a proposed AD. The proposed AD applies to GE CF34-10E series
turbofan engines. We published the proposed AD in the Federal Register
on January 17, 2007 (72 FR 1946). That action proposed to require
revising the combustor case published life limit and removing combustor
cases from service before reaching a reduced life limit.
Examining the AD Docket
You may examine the docket that contains the AD, any comments
received, and any final disposition in person at the Docket Management
Facility between 9 a.m. and 5 p.m., Monday through Friday, except
Federal holidays. The Docket Office (telephone (800) 647-5227) is
located on the plaza level of the Department of Transportation Nassif
Building at the street address stated in ADDRESSES. Comments will be
available in the AD docket shortly after the DMS receives them.
Comments
We provided the public the opportunity to participate in the
development of this AD. We received no comments on the proposal or on
the determination of the cost to the public.
Elimination of Paragraph (g)
After we issued the proposed AD, our review indicated that we
should simplify the compliance by eliminating paragraph (g). That
paragraph is redundant to paragraph (f), and would only add an
additional requirement for the operators to show compliance after
removal of every affected part. We eliminated the proposed AD paragraph
(g), and re-codified the paragraphs, in this AD.
Conclusion
We have carefully reviewed the available data and determined that
air safety and the public interest require adopting the AD as proposed.
Costs of Compliance
We estimate that this AD will affect 42 CF34-10E series turbofan
engines installed on airplanes of U.S. registry. This combustor case
removal does not impose any additional labor costs if performed at the
time of scheduled engine overhaul. The financial burden to the
operators (prorate) is about $140,080 per engine due to the reduction
in the life limit. Based on these figures, and on the prorating for the
usage of the combustor cases, we estimate the cost of the AD on U.S.
operators to be $5,886,720.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to
issue rules on aviation safety. Subtitle I, Section 106, describes the
authority of the FAA Administrator. Subtitle VII, Aviation Programs,
describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in
Subtitle VII, Part A, Subpart III, Section 44701, ``General
requirements.'' Under that section, Congress charges the FAA with
promoting safe flight of civil aircraft in air commerce by prescribing
regulations for practices, methods, and procedures the Administrator
finds necessary for safety in air commerce. This regulation is within
the scope of that authority because it addresses an unsafe condition
that is likely to exist or develop on products identified in this
rulemaking action.
Regulatory Findings
We have determined that this AD will not have federalism
implications under Executive Order 13132. This AD will not have a
substantial direct effect on the States, on the relationship between
the national government and the States, or on the distribution of power
and responsibilities among the various levels of government.
For the reasons discussed above, I certify that this AD:
(1) Is not a ``significant regulatory action'' under Executive
Order 12866;
(2) Is not a ``significant rule'' under DOT Regulatory Policies and
Procedures (44 FR 11034, February 26, 1979); and
(3) Will not have a significant economic impact, positive or
negative, on a substantial number of small entities under the criteria
of the Regulatory Flexibility Act.
We prepared a summary of the costs to comply with this AD and
placed it in the AD Docket. You may get a copy of this summary at the
address listed under ADDRESSES.
[[Page 30956]]
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
Adoption of the Amendment
0
Accordingly, under the authority delegated to me by the Administrator,
the Federal Aviation Administration amends 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
0
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
0
2. The FAA amends Sec. 39.13 by adding the following new airworthiness
directive:
2007-12-09 General Electric Company: Amendment 39-15087. Docket No.
FAA-2006-26585; Directorate Identifier 2006-NE-44-AD.
Effective Date
(a) This airworthiness directive (AD) becomes effective July 10,
2007.
Affected ADs
(b) None.
Applicability
(c) This AD applies to General Electric Company (GE) CF34-
10E2A1, CF34-10E5, CF34-10E5A1, CF34-10E6, CF34-10E6A1, and CF34-
10E7 turbofan engines. These engines are installed on, but not
limited to, Embraer ERJ-190 and -195 airplanes.
Unsafe Condition
(d) This AD results from GE's evaluation of the effects to the
combustor case due to installing version 5.10 software in the full-
authority digital electronic control (FADEC), and revising the
combustor case published life limit. We are issuing this AD to
prevent uncontained combustor case failure resulting in an in-flight
engine shutdown and possible damage to the airplane.
Compliance
(e) You are responsible for having the actions required by this
AD performed within 30 days after the effective date of this AD,
unless the actions have already been done.
(f) Revise the published life limit in the Airworthiness
Limitations Section of the CF34-10E Engine Manual, for combustor
cases, part number (P/N) 2070M47G02 and P/N 2070M47G03, from 39,600
cycles-since-new (CSN) to 24,600 CSN.
(g) The requirements of this AD have been met when the engine
manual changes are made and operators have modified their continuous
airworthiness maintenance plans to reflect the Engine Maintenance
Program requirements specified in the GE CF34-10E Engine Manual.
Alternative Methods of Compliance
(h) The Manager, Engine Certification Office, has the authority
to approve alternative methods of compliance for this AD if
requested using the procedures found in 14 CFR 39.19.
Related Information
(i) Contact Tara Chaidez, Aerospace Engineer, Engine
Certification Office, FAA, Engine and Propeller Directorate, 12 New
England Executive Park, Burlington, MA 01803; e-mail:
tara.chaidez@faa.gov; telephone (781) 238-7773, fax (781) 238-7199,
for more information about this AD.
Issued in Burlington, Massachusetts, on May 30, 2007.
Robert Ganley,
Acting Manager, Engine and Propeller Directorate, Aircraft
Certification Service.
[FR Doc. E7-10746 Filed 6-4-07; 8:45 am]
BILLING CODE 4910-13-P