[Federal Register: October 24, 2007 (Volume 72, Number 205)]
[Rules and Regulations]
[Page 60227-60228]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr24oc07-1]
========================================================================
Rules and Regulations
Federal Register
________________________________________________________________________
This section of the FEDERAL REGISTER contains regulatory documents
having general applicability and legal effect, most of which are keyed
to and codified in the Code of Federal Regulations, which is published
under 50 titles pursuant to 44 U.S.C. 1510.
The Code of Federal Regulations is sold by the Superintendent of Documents.
Prices of new books are listed in the first FEDERAL REGISTER issue of each
week.
========================================================================
[[Page 60227]]
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 39
[Docket No. FAA-2007-28319; Directorate Identifier 2007-NE-27-AD;
Amendment 39-15243; AD 2007-22-07]
RIN 2120-AA64
Airworthiness Directives; General Electric Company (GE) CF6-
80C2D1F Turbofan Engines
AGENCY: Federal Aviation Administration (FAA), Department of
Transportation (DOT).
ACTION: Final rule.
-----------------------------------------------------------------------
SUMMARY: The FAA is adopting a new airworthiness directive (AD) for GE
CF6-80C2D1F turbofan engines, installed on, but not limited to,
McDonnell Douglas Corporation MD-11 series airplanes. This AD requires
removing previous software versions from the engine electronic control
unit (ECU). Engines with new version software will have increased
margin to flameout. This AD results from reports of engine flameout
events during flight, including reports of events where all engines
simultaneously experienced a flameout or other adverse operation.
Although the root cause investigation is not yet complete, we believe
that exposure to ice crystals during flight is associated with these
flameout events. We are issuing this AD to minimize engine flameout
caused by ice accretion and shedding during flight.
DATES: This AD becomes effective November 28, 2007.
ADDRESSES: You can get the service information identified in this AD
from General Electric Company via Lockheed Martin Technology Services,
10525 Chester Road, Suite C, Cincinnati, Ohio 45215, telephone (513)
672-8400, fax (513) 672-8422.
The Docket Operations office is located at U.S. Department of
Transportation, Docket Operations, M-30, West Building Ground Floor,
Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590.
FOR FURTHER INFORMATION CONTACT: John Golinski, Aerospace Engineer,
Engine Certification Office, FAA, Engine and Propeller Directorate, 12
New England Executive Park, Burlington, MA 01803; e-mail:
john.golinski@faa.gov; telephone: (781) 238-7135, fax: (781) 238-7199.
SUPPLEMENTARY INFORMATION: The FAA proposed to amend 14 CFR part 39
with a proposed AD. The proposed AD applies to GE CF6-80C2D1F turbofan
engines, installed on McDonnell Douglas Corporation MD-11 series
airplanes. We published the proposed AD in the Federal Register on July
17, 2007 (72 FR 39039). That action proposed to require removing
previous software versions from the engine ECU.
Examining the AD Docket
You may examine the AD docket on the Internet at http://www.regulations.gov
; or in person at the Docket Operations office
between 9 a.m. and 5 p.m., Monday through Friday, except Federal
holidays. The AD docket contains this AD, the regulatory evaluation,
any comments received, and other information. The street address for
the Docket Operations office (telephone (800) 647-5527) is the same as
the Mail address provided in the ADDRESSES section. Comments will be
available in the AD docket shortly after receipt.
Comments
We provided the public the opportunity to participate in the
development of this AD. We have considered the comments received.
Request for Clarification
Boeing and GE request clarification of the statement that the AD
action results from reports of engine flameout events during flight,
including reports of events where all engines simultaneously
experienced a flameout or other adverse operation. The commenters point
out that there have been no all-engine flameout events on MD-11 series
airplanes.
We disagree. While we agree that no all-engine flameout events on
the MD-11 have occurred, single and multiple engine flameout events
have taken place. We did not change the AD.
Conclusion
We have carefully reviewed the available data, including the
comments received, and determined that air safety and the public
interest require adopting the AD as proposed.
Costs of Compliance
We estimate that this AD will affect 175 CF6-80C2D1F turbofan
engines installed on McDonnell Douglas Corporation MD-11 series
airplanes of U.S. registry. We estimate it will take about 6 work-hours
per ECU. The average labor rate is $80 per work-hour. Based on these
figures, we estimate the cost to U.S. operators to be $63,120. Our cost
estimate is exclusive of warranty coverage.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to
issue rules on aviation safety. Subtitle I, Section 106, describes the
authority of the FAA Administrator. Subtitle VII, Aviation Programs,
describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in
Subtitle VII, Part A, Subpart III, Section 44701, ``General
requirements.'' Under that section, Congress charges the FAA with
promoting safe flight of civil aircraft in air commerce by prescribing
regulations for practices, methods, and procedures the Administrator
finds necessary for safety in air commerce. This regulation is within
the scope of that authority because it addresses an unsafe condition
that is likely to exist or develop on products identified in this
rulemaking action.
Regulatory Findings
We have determined that this AD will not have federalism
implications under Executive Order 13132. This AD will not have a
substantial direct effect on the States, on the relationship between
the national government and the States, or on the distribution of power
and responsibilities among the various levels of government.
For the reasons discussed above, I certify that this AD:
(1) Is not a ``significant regulatory action'' under Executive
Order 12866;
[[Page 60228]]
(2) Is not a ``significant rule'' under DOT Regulatory Policies and
Procedures (44 FR 11034, February 26, 1979); and
(3) Will not have a significant economic impact, positive or
negative, on a substantial number of small entities under the criteria
of the Regulatory Flexibility Act.
We prepared a summary of the costs to comply with this AD and
placed it in the AD Docket. You may get a copy of this summary at the
address listed under ADDRESSES.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
Adoption of the Amendment
0
Accordingly, under the authority delegated to me by the Administrator,
the Federal Aviation Administration amends 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
0
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
0
2. The FAA amends Sec. 39.13 by adding the following new airworthiness
directive:
2007-22-07 General Electric Company: Amendment 39-15243. Docket No.
FAA-2007-28319; Directorate Identifier 2007-NE-27-AD.
Effective Date
(a) This airworthiness directive (AD) becomes effective November
28, 2007.
Affected ADs
(b) None.
Applicability
(c) This AD applies to General Electric Company (GE) CF6-80C2D1F
turbofan engines, installed on, but not limited to, McDonnell
Douglas Corporation MD-11 series airplanes.
Unsafe Condition
(d) This AD results from reports of engine flameout events
during flight, including reports of events where all engines
simultaneously experienced a flameout or other adverse operation. We
are issuing this AD to minimize engine flameout due to ice accretion
and shedding during flight. Exposure to ice crystals during flight
is believed to be associated with these flameout events.
Compliance
(e) You are responsible for having the actions required by this
AD performed within the compliance times specified unless the
actions have already been done.
Interim Action
(f) These actions are interim actions due to the on-going
investigation, and we may take further rulemaking actions in the
future based on the results of the investigation and field
experience.
Engine Electronic Control Unit (ECU) Software Removal
(g) At the next shop visit of the engine or of the ECU,
whichever occurs first, and not to exceed 60 months from the
effective date of this AD, remove the following software versions
from the ECUs:
Table 1.--Removal of ECU Software Versions
------------------------------------------------------------------------
Software version Installed in ECU Part No.
------------------------------------------------------------------------
(1) 8.5.A......................... 1851M51P01, 1851M51P02, 1851M52P01,
1851M52P02, 1851M53P01, 1851M53P02
(2) 8.3C.......................... 1471M69P01, 1471M69P02, 1519M91P01
(3) 8.3.D......................... 1519M91P02
(4) 8.3.E......................... 1519M91P03, 1519M91P04
(5) 8.3.F......................... 1519M91P05
(6) 8.3.G......................... 1519M91P06, 1820M34P01
(7) 8.3.H......................... 1519M91P07, 1820M34P02
(8) 8.3.J......................... 1519M91P09, 1519M91P10, 1820M34P04,
1820M34P05
------------------------------------------------------------------------
Previous Software Versions of ECU Software
(h) For a period of 24 months after the effective date of this
AD, once an ECU containing a software version not listed in Table 1
of this AD is installed on an engine, that ECU can be replaced with
an ECU containing a previous version of software listed in Table 1.
(i) Once the software version listed in Table 1 of this AD has
been removed and new FAA-approved software version is installed in
an ECU, reverting to those older software versions in that ECU is
prohibited.
(j) After 60 months from the effective date of this AD, use of
an ECU with a software version listed in Table 1 of this AD is
prohibited.
Definitions
(k) For the purposes of this AD:
(1) Next shop visit of the ECU is when the ECU is removed from
the engine for overhaul or maintenance after the effective date of
this AD.
(2) Next shop visit of the engine is when the engine is removed
from the airplane for maintenance in which a major flange is
disassembled after the effective date of this AD. The following
engine maintenance actions, either separately or in combination with
each other, are not considered a next shop visit of the engine:
(i) Removal of the upper high pressure compressor (HPC) stator
case solely for airfoil maintenance.
(ii) Module-level inspection of the HPC rotor stages 3-9 spool.
(iii) Replacement of stage 5 HPC variable stator vane bushings
or lever arms.
(iv) Removal of the accessory gearbox.
(v) Replacement of the inlet gearbox polytetrafluoroethylene
seal.
Alternative Methods of Compliance
(l) The Manager, Engine Certification Office, has the authority
to approve alternative methods of compliance for this AD if
requested using the procedures found in 14 CFR 39.19.
Special Flight Permits
(m) Special flight permits are not authorized.
Related Information
(n) Information on removing ECU software and installing new
software, which provides increased margin to flameout, can be found
in GE Service Bulletin No. CF6-80C2 S/B 73-0351, dated April 11,
2007.
(o) Contact John Golinski, Aerospace Engineer, Engine
Certification Office, FAA, Engine and Propeller Directorate, 12 New
England Executive Park, Burlington, MA 01803; e-mail:
john.golinski@faa.gov; telephone: (781) 238-7135, fax: (781) 238-
7199, for more information about this AD.
Issued in Burlington, Massachusetts, on October 17, 2007.
Peter A. White,
Acting Manager, Engine and Propeller Directorate, Aircraft
Certification Service.
[FR Doc. E7-20813 Filed 10-23-07; 8:45 am]
BILLING CODE 4910-13-P