[Federal Register: January 3, 2008 (Volume 73, Number 2)]
[Rules and Regulations]
[Page 394-395]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr03ja08-2]
-----------------------------------------------------------------------
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 39
[Docket No. FAA-2007-27230; Directorate Identifier 2007-NE-04-AD]
Amendment 39-15322; AD 2007-26-20]
RIN 2120-AA64
Airworthiness Directives; Pratt & Whitney (PW) PW4164, PW4168,
and PW4168A Turbofan Engines
AGENCY: Federal Aviation Administration (FAA), Department of
Transportation (DOT).
ACTION: Final rule.
-----------------------------------------------------------------------
SUMMARY: The FAA is adopting a new airworthiness directive (AD) for PW
PW4164, PW4168, and PW4168A turbofan engines with certain low pressure
turbine (LPT) stage 4 disks, part number (P/N) 51N404, installed. This
AD requires removing certain LPT stage 4 disks, listed by serial number
at the next piece-part exposure or within 7,500 cycles-since-new (CSN).
This AD results from a report of improperly manufactured LPT stage 4
disks. We are issuing this AD to prevent an uncontained engine failure
due to low-cycle fatigue (LCF), which could result in damage to the
airplane.
DATES: This AD becomes effective February 7, 2008.
ADDRESSES: The Docket Operations office is located at Docket Management
Facility, U.S. Department of Transportation, 1200 New Jersey Avenue,
SE., West Building, Ground Floor, Room W12-140, Washington, DC 20590-
0001.
FOR FURTHER INFORMATION CONTACT: V. Rose Len, Aerospace Engineer,
Engine Certification Office, FAA, Engine & Propeller Directorate, 12
New England Executive Park, Burlington, MA 01803; telephone (781) 238-
7772; fax (781) 238-7199.
SUPPLEMENTARY INFORMATION: The FAA proposed to amend 14 CFR part 39
with a proposed AD. The proposed AD applies to PW PW4164, PW4168, and
PW4168A. We published the proposed AD in the Federal Register on May
21, 2007 (72 FR 28459). That action proposed to require removing
certain LPT stage 4 disks, P/N 51N404, listed by serial number in the
proposed AD, at the next piece-part exposure, or within 7,500 CSN,
whichever occurs first.
Examining the AD Docket
You may examine the AD docket on the Internet at http://www.regulations.gov
; or in person at the Docket Operations office
between 9 a.m. and 5 p.m., Monday through Friday, except Federal
holidays. The AD docket contains this AD, the regulatory evaluation,
any comments received, and other information. The street address for
the Docket Operations office (telephone (800) 647-5527) is provided in
the ADDRESSES section. Comments will be available in the AD docket
shortly after receipt.
Comments
We provided the public the opportunity to participate in the
development of this AD. We have considered the comment received.
Pratt & Whitney proposes that we not write an AD. Pratt & Whitney
states that they performed additional testing for low-cycle fatigue
(LCF). They state the testing shows the disks with the 1-hour heat
treatment are equivalent to the disks treated with a 4-hour heat
treatment. We do not agree. The data that PW presents to us doesn't
conclusively show the 1-hour heat-treat LCF capability is equivalent to
the 4-hour heat-treat disks. We didn't change the AD.
Conclusion
We have carefully reviewed the available data, including the
comment received, and determined that air safety and the public
interest require adopting the AD as proposed.
Costs of Compliance
We estimate that this AD will affect 11 engines installed on
airplanes of U.S. registry. We also estimate that it will take about
250 work-hours per engine to perform the required action, if not done
at piece-part exposure, and that the average labor rate is $80 per
work-hour. Required parts will cost about $186,288
[[Page 395]]
per engine. Based on these figures, we estimate the total cost of the
AD to U.S. operators to be $2,269,168.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to
issue rules on aviation safety. Subtitle I, Section 106, describes the
authority of the FAA Administrator. Subtitle VII, Aviation Programs,
describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in
Subtitle VII, Part A, Subpart III, Section 44701, ``General
requirements.'' Under that section, Congress charges the FAA with
promoting safe flight of civil aircraft in air commerce by prescribing
regulations for practices, methods, and procedures the Administrator
finds necessary for safety in air commerce. This regulation is within
the scope of that authority because it addresses an unsafe condition
that is likely to exist or develop on products identified in this
rulemaking action.
Regulatory Findings
We have determined that this AD will not have federalism
implications under Executive Order 13132. This AD will not have a
substantial direct effect on the States, on the relationship between
the national government and the States, or on the distribution of power
and responsibilities among the various levels of government.
For the reasons discussed above, I certify that this AD:
(1) Is not a ``significant regulatory action'' under Executive
Order 12866;
(2) Is not a ``significant rule'' under DOT Regulatory Policies and
Procedures (44 FR 11034, February 26, 1979); and
(3) Will not have a significant economic impact, positive or
negative, on a substantial number of small entities under the criteria
of the Regulatory Flexibility Act.
We prepared a summary of the costs to comply with this AD and
placed it in the AD Docket. You may get a copy of this summary at the
address listed under ADDRESSES.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
Adoption of the Amendment
0
Accordingly, under the authority delegated to me by the Administrator,
the Federal Aviation Administration amends 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
0
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
0
2. The FAA amends Sec. 39.13 by adding the following new airworthiness
directive:
2007-26-20 Pratt & Whitney: Amendment 39-15322. Docket No. FAA-2007-
27230; Directorate Identifier 2007-NE-04-AD.
Effective Date
(a) This airworthiness directive (AD) becomes effective February
7, 2008.
Affected ADs
(b) None.
Applicability
(c) This AD applies to Pratt & Whitney PW4164, PW4168, and
PW4168A turbofan engines with certain low pressure turbine (LPT)
stage 4 disks, part number (P/N) 51N404, that have a serial number
(S/N) listed in the following Table 1, installed. These engines are
installed on, but not limited to, Airbus A330-200 and A330-300
series airplanes.
Table 1.--Affected LPT Stage 4 Disks by Serial Number
------------------------------------------------------------------------
-------------------------------------------------------------------------
LPT Stage 4 Disk Serial Nos.
------------------------------------------------------------------------
CLDLC01142
CLDLC01143
CLDLC01144
CLDLC01145
CLDLC01146
CLDLC01148
CLDLC01149
CLDLC01150
CLDLC01151
CLDLC01152
CLDLC01181
CLDLC01182
CLDLC01183
CLDLC01185
CLDLC01186
CLDLC01187
------------------------------------------------------------------------
Unsafe Condition
(d) This AD results from a report of improperly manufactured LPT
stage 4 disks. We are issuing this AD to prevent an uncontained
engine failure due to low-cycle fatigue, which could result in
damage to the airplane.
Compliance
(e) You are responsible for having the actions required by this
AD performed at the next piece-part exposure after the effective
date of this AD or within 7,500 cycles-since-new, unless the actions
have already been done.
Removing the LPT Stage 4 Disk
(f) Remove from service any LPT stage 4 disk that has an S/N
listed in Table 1 of this AD.
Prohibition Against Installing an Affected Disk
(g) After the effective date of this AD, do not install any
disk, P/N 51N404, that has an S/N listed in Table 1 of this AD or
any disk removed as specified in paragraph (f) of this AD except as
allowed by paragraph (h) of this AD.
Alternative Methods of Compliance
(h) The Manager, Engine Certification Office, has the authority
to approve alternative methods of compliance for this AD if
requested using the procedures found in 14 CFR 39.19.
Special Flight Permits
(i) Under 14 CFR part 39.23, we are prohibiting the special
flight permits for this AD.
Related Information
(j) Contact V. Rose Len, Aerospace Engineer, Engine
Certification Office, FAA, Engine & Propeller Directorate, 12 New
England Executive Park, Burlington, MA 01803; telephone (781) 238-
7772; fax (781) 238-7199, for more information about this AD.
Material Incorporated by Reference
(k) None.
Issued in Burlington, Massachusetts, on December 20, 2007.
Peter A. White,
Assistant Manager, Engine and Propeller Directorate, Aircraft
Certification Service.
[FR Doc. E7-25505 Filed 1-2-08; 8:45 am]
BILLING CODE 4910-13-P