[Federal Register: January 23, 2008 (Volume 73, Number 15)]
[Proposed Rules]
[Page 3889-3891]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr23ja08-14]
-----------------------------------------------------------------------
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 39
[Docket No. FAA-2008-0039; Directorate Identifier 2006-SW-13-AD]
RIN 2120-AA64
Airworthiness Directives; Bell Helicopter Textron Canada Model
222, 222B, 222U, 230 and 430 Helicopters
AGENCY: Federal Aviation Administration, DOT.
ACTION: Notice of proposed rulemaking (NPRM).
-----------------------------------------------------------------------
SUMMARY: This document proposes adopting a new airworthiness directive
(AD) for Bell Helicopter Textron Canada (BHTC) Model 222, 222B, 222U,
230 and 430 helicopters. This proposal would require rewiring and
testing the fuel valve switch on each engine and testing the ignitor
system. This proposal is prompted by an in-flight incident in which a
fuel valve switch failed, causing the fuel valve to inadvertently
close. The actions specified by this proposed AD are intended to
prevent interruption of the fuel supply caused by failure of the fuel
switch, which could result in loss of engine power and subsequent loss
of control of the helicopter.
DATES: Comments must be received on or before March 24, 2008.
ADDRESSES: Use one of the following addresses to submit comments on
this proposed AD:
Federal eRulemaking Portal: Go to http://www.regulations.gov.
Follow the instructions for submitting comments.
Fax: 202-493-2251.
Mail: U.S. Department of Transportation, Docket
Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New
Jersey Avenue, SE., Washington, DC 20590.
Hand Delivery: U.S. Department of Transportation, Docket
Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New
Jersey Avenue, SE., Washington, DC 20590, between 9 a.m. and 5 p.m.,
Monday through Friday, except Federal holidays.
You may get the service information identified in this proposed AD
from Bell Helicopter Textron Canada, 12,800 Rue de l'Avenir, Mirabel,
Quebec J7J1R4, telephone (450) 437-2862 or (800) 363-8023, fax (450)
433-0272.
You may examine the comments to this proposed AD in the AD docket
on the Internet at http://www.regulations.gov.
FOR FURTHER INFORMATION CONTACT: Carroll Wright, Aviation Safety
Engineer, FAA, Rotorcraft Directorate, Regulations and Policy Group,
Fort Worth, Texas 76193-0110, telephone (817) 222-5120, fax (817) 222-
5961.
SUPPLEMENTARY INFORMATION:
Comments Invited
We invite you to submit any written data, views, or arguments
regarding this proposed AD. Send your comments to the address listed
under the caption ADDRESSES. Include the docket number ``FAA-2008-0039,
Directorate Identifier 2006-SW-13-AD'' at the beginning of your
comments. We specifically invite comments on the overall regulatory,
economic, environmental, and energy aspects of the proposed AD. We will
consider all comments received by the closing date and may amend the
proposed AD in light of those comments.
We will post all comments we receive, without change, to http://www.regulations.gov
, including any personal information you provide. We
will also post a report summarizing each substantive verbal contact
with FAA personnel concerning this proposed rulemaking. Using the
search function of our docket web site, you can find and read the
comments to any of our dockets, including the name of the individual
who sent or signed the comment. You may review the DOT's complete
Privacy Act Statement in the Federal Register published on April 11,
2000 (65 FR 19477-78), or you may visit http://www.regulations.gov.
Examining the Docket
You may examine the docket that contains the proposed AD, any
comments, and other information in person at the Docket Operations
office between 9 a.m. and 5 p.m., Monday through Friday, except Federal
holidays. The Docket Operations office (telephone (800) 647-5527) is
located in Room W12-140 on the ground floor of the West Building at the
street address stated in the ADDRESSES section. Comments will be
available in the AD docket shortly after receipt.
Discussion
This document proposes adopting a new AD for the following BHTC
helicopters:
[[Page 3890]]
------------------------------------------------------------------------
Model No. Serial Nos.
------------------------------------------------------------------------
222................................ 47006 through 47089.
222B............................... 47131 through 47156.
222U............................... 47501 through 47574.
230................................ 23001 through 23038.
430................................ 49001 through 49101.
------------------------------------------------------------------------
This proposal would require, within 50 hours time-in-service (TIS),
rewiring the switches that control the operation of the No. 1 and No. 2
engines' fuel valves, and testing the switches and the ignitor system.
This proposal is prompted by an in-flight incident in which a fuel
valve switch failed. The manufacturer reports that there is a
possibility that a switch may fail during flight due to vibration,
causing the switch to open and then causing the fuel valve to close,
resulting in inadvertent shut down of an engine. The actions specified
by this proposed AD are intended to prevent interruption of the fuel
supply caused by failure of the fuel switch, which could result in loss
of engine power and subsequent loss of control of the helicopter.
Transport Canada, the airworthiness authority for Canada, notified
the FAA that an unsafe condition may exist on BHTC Model 222, 222B,
222U, 230 and 430 helicopters. Transport Canada advises of an
investigation into an incident involving a BHTC Model 222 helicopter,
in which the fuel shut-off switch, part number (P/N) 10648BH1-1, failed
during flight causing the fuel valve to close and the engine to shut
down. Review of the Service Difficulty Report database identified two
other incidents of switch failure.
Bell Helicopter Textron has issued the following technical
bulletins, all dated June 11, 2003, which specify rewiring the fuel
valve switch:
------------------------------------------------------------------------
Technical bulletin Helicopter models affected
------------------------------------------------------------------------
No. 222-03-171........................ Model 222 and 222B helicopters.
No. 222U-03-96........................ Model 222U helicopters.
No. 230-03-35......................... Model 230 helicopters.
No. 430-03-33......................... Model 430 helicopters.
------------------------------------------------------------------------
Transport Canada classified these technical bulletins as mandatory and
issued AD No. CF-2006-03, dated February 28, 2006, to ensure the
continued airworthiness of these helicopters in Canada. That AD
requires compliance no later than May 3, 2006. This proposal would
require compliance within 50 hours TIS.
This helicopter model is manufactured in Canada and is type
certificated for operation in the United States under the provisions of
14 CFR 21.29 and the applicable bilateral agreement. Pursuant to the
applicable bilateral agreement, Transport Canada has kept us informed
of the situation described above. We have examined the findings of
Transport Canada, reviewed all available information, and determined
that AD action is necessary for products of these type designs that are
certificated for operation in the United States.
This previously described unsafe condition is likely to exist or
develop on other helicopters of these same type designs registered in
the United States. Therefore, the proposed AD would require, within 50
hours TIS, rewiring the switches, P/N 10648BH1-1, located in the
cockpit overhead console, that control the operation of the No. 1 and
No. 2 engines' fuel valves. The actions would be required to be
accomplished by following the specified portions of the technical
bulletins described previously.
We estimate that this proposed AD would affect 165 helicopters of
U.S. registry and the proposed actions would take approximately four
work hours per helicopter to rewire the 2 fuel valve switches, and test
those switches and the ignitor system at an average labor rate of $80
per work hour. Based on these figures, we estimate the total cost
impact of the proposed AD on U.S. operators to be $52,800 ($320 per
helicopter).
Regulatory Findings
We have determined that this proposed AD would not have federalism
implications under Executive Order 13132. Additionally, this proposed
AD would not have a substantial direct effect on the States, on the
relationship between the national Government and the States, or on the
distribution of power and responsibilities among the various levels of
government.
For the reasons discussed above, I certify that the proposed
regulation:
1. Is not a ``significant regulatory action'' under Executive Order
12866;
2. Is not a ``significant rule'' under the DOT Regulatory Policies
and Procedures (44 FR 11034, February 26, 1979); and
3. Will not have a significant economic impact, positive or
negative, on a substantial number of small entities under the criteria
of the Regulatory Flexibility Act.
We prepared a draft economic evaluation of the estimated costs to
comply with this proposed AD. See the AD docket to examine the draft
economic evaluation.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to
issue rules on aviation safety. Subtitle I, Section 106, describes the
authority of the FAA Administrator. Subtitle VII, Aviation Programs,
describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in
Subtitle VII, Part A, Subpart III, Section 44701, ``General
requirements.'' Under that section, Congress charges the FAA with
promoting safe flight of civil aircraft in air commerce by prescribing
regulations for practices, methods, and procedures the Administrator
finds necessary for safety in air commerce. This regulation is within
the scope of that authority because it addresses an unsafe condition
that is likely to exist or develop on products identified in this
rulemaking action.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
The Proposed Amendment
Accordingly, pursuant to the authority delegated to me by the
Administrator, the Federal Aviation Administration proposes to amend
part 39 of the Federal Aviation Regulations (14 CFR part 39) as
follows:
PART 39--AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
2. Section 39.13 is amended by adding a new airworthiness directive
to read as follows:
Bell Helicopter Textron Canada: Docket No. FAA-2008-0039;
Directorate Identifier 2006-SW-13-AD.
Applicability: The following model helicopters, certificated in
any category:
------------------------------------------------------------------------
Model No. Serial Nos.
------------------------------------------------------------------------
222................................ 47006 through 47089.
222B............................... 47131 through 47156.
222U............................... 47501 through 47574.
230................................ 23001 through 23038.
430................................ 49001 through 49101.
------------------------------------------------------------------------
Compliance: Required within 50 hours time-in-service, unless
accomplished previously.
To prevent interruption of the fuel supply caused by failure of
the fuel switch, which could result in loss of engine power and
subsequent loss of control of the helicopter, accomplish the
following:
(a) Rewire the No. 1 and No. 2 engines' fuel valve switch, part
number 10648BH1-1, and test the fuel valve switches and the ignitor
system, in accordance with the
[[Page 3891]]
Accomplishment Instructions in Bell Helicopter Textron Technical
Bulletin (TB) No. 222-03-171, Part 1, applicable to Model 222
helicopters, serial number (S/N) 47006-47038, and Part 2, applicable
to Model 222 helicopters, S/N 47039-47089, and Model 222B
helicopters, S/N 47131-47156; TB No. 222U-03-96, applicable to Model
222U helicopters; TB No. 230-03-35, applicable to Model 230
helicopters; and TB No. 430-03-33, applicable to Model 430
helicopters. All of the technical bulletins are dated June 11, 2003.
(b) To request a different method of compliance or a different
compliance time for this AD, follow the procedures in 14 CFR 39.19.
Contact the Manager, Regulations and Policy Group, FAA, ATTN:
Carroll Wright, 2601 Meacham Blvd., Fort Worth, Texas 76193-0110,
telephone (817) 222-5120, fax (817) 222-5961, for information about
previously approved alternative methods of compliance.
Note: The subject of this AD is addressed in Transport Canada
(Canada) AD CF-2006-03, dated February 28, 2006.
Issued in Fort Worth, Texas, on January 8, 2008.
Mark R. Schilling,
Acting Manager, Rotorcraft Directorate, Aircraft Certification Service.
[FR Doc. E8-1026 Filed 1-22-08; 8:45 am]
BILLING CODE 4910-13-P