[Federal Register: September 25, 2008 (Volume 73, Number 187)]
[Proposed Rules]
[Page 55456-55458]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr25se08-16]
========================================================================
Proposed Rules
Federal Register
________________________________________________________________________
This section of the FEDERAL REGISTER contains notices to the public of
the proposed issuance of rules and regulations. The purpose of these
notices is to give interested persons an opportunity to participate in
the rule making prior to the adoption of the final rules.
========================================================================
[[Page 55456]]
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 39
[Docket No. FAA-2008-1019; Directorate Identifier 2007-NE-49-AD]
RIN 2120-AA64
Airworthiness Directives; Honeywell International Inc. LTS101
Series Turboshaft and LTP101 Series Turboprop Engines
AGENCY: Federal Aviation Administration (FAA), Department of
Transportation (DOT).
ACTION: Notice of proposed rulemaking (NPRM).
-----------------------------------------------------------------------
SUMMARY: The FAA proposes to adopt a new airworthiness directive (AD)
for Honeywell International Inc. LTS101 series turboshaft and LTP101
series turboprop engines with certain gas generator turbine discs
installed. This proposed AD would require reducing the life limits for
certain gas generator turbine discs. This proposed AD results from an
error in a change to the engineering drawing for the gas generator
turbine disc from which they manufactured 260 discs. We are proposing
this AD to prevent rupture of the gas generator turbine disc, which
could result in uncontained engine failure and damage to the aircraft.
DATES: We must receive any comments on this proposed AD by November 24,
2008.
ADDRESSES: Use one of the following addresses to comment on this
proposed AD.
Federal eRulemaking Portal: Go to http://
www.regulations.gov and follow the instructions for sending your
comments electronically.
Mail: Docket Management Facility, U.S. Department of
Transportation, 1200 New Jersey Avenue, SE., West Building Ground
Floor, Room W12-140, Washington, DC 20590-0001.
Hand Delivery: Deliver to Mail address above between 9
a.m. and 5 p.m., Monday through Friday, except Federal holidays.
Fax: (202) 493-2251.
You can get the service information identified in this proposed AD
from Honeywell International Inc., P.O. Box 52181, Phoenix, AZ 85072-
2181, U.S.A.; telephone (800) 601-3099 (U.S.A.) or (602) 365-3099
(International); Web site: http://portal.honeywell.com/wps/portal/aero.
FOR FURTHER INFORMATION CONTACT: Robert Baitoo, Aerospace Engineer, Los
Angeles Aircraft Certification Office, FAA, Transport Airplane
Directorate, 3960 Paramount Blvd., Lakewood, CA 90712-4137; e-mail:
robert.baitoo@faa.gov; telephone (562) 627-5245; fax (562) 627-5210.
SUPPLEMENTARY INFORMATION:
Comments Invited
We invite you to send us any written relevant data, views, or
arguments regarding this proposal. Send your comments to an address
listed under ADDRESSES. Include ``Docket No. FAA-2008-1019; Directorate
Identifier 2007-NE-49-AD'' in the subject line of your comments. We
specifically invite comments on the overall regulatory, economic,
environmental, and energy aspects of the proposed AD. We will consider
all comments received by the closing date and may amend the proposed AD
in light of those comments.
We will post all comments we receive, without change, to http://
www.regulations.gov, including any personal information you provide. We
will also post a report summarizing each substantive verbal contact
with FAA personnel concerning this proposed AD. Using the search
function of the Web site, anyone can find and read the comments in any
of our dockets, including, if provided, the name of the individual who
sent the comment (or signed the comment on behalf of an association,
business, labor union, etc.). You may review the DOT's complete Privacy
Act Statement in the Federal Register published on April 11, 2000 (65
FR 19477-78).
Examining the AD Docket
You may examine the AD docket on the Internet at http://
www.regulations.gov; or in person at the Docket Operations office
between 9 a.m. and 5 p.m., Monday through Friday, except Federal
holidays. The AD docket contains this proposed AD, the regulatory
evaluation, any comments received, and other information. The street
address for the Docket Operations office (telephone (800) 647-5527) is
the same as the Mail address provided in the ADDRESSES section.
Comments will be available in the AD docket shortly after receipt.
Discussion
Honeywell International Inc. has informed us that they manufactured
260 gas generator turbine discs to an erroneous drawing change. Because
of this, the gas generator turbine disc could rupture before reaching
its published life limit. This condition, if not corrected, could
result in uncontained engine failure and damage to the aircraft.
Relevant Service Information
We have reviewed and approved the technical contents of Honeywell
International Inc. Service Bulletin (SB) LT 101-71-00-0002, Revision
25, dated August 31, 2007, that describes a reduced life limit and
drawdown schedules for certain gas generator turbine discs and lists
the serial numbers of those discs.
Differences Between the Proposed AD and the Manufacturer's Service
Information
Although the SB applies to all LTS101 turboshaft engines and LTP101
turboprop engines, this proposed AD would not apply to models LTS101-
700D-2 and LTS101-850B-2 turboshaft engines because the affected discs
are not eligible for installation on those engine models. We also
revised the drawdown schedules in Table 1 of this proposed AD to make
the grace periods consistent.
FAA's Determination and Requirements of the Proposed AD
We have evaluated all pertinent information and identified an
unsafe condition that is likely to exist or develop on other products
of this same type design. We are proposing this AD, which would require
removing any disc, part number (P/N) 4-111-015-14 that has a serial
number (SN) listed in Appendix 1 of SB LT 101-71-00-0002, Revision 25,
dated August 31, 2007, using the drawdown schedules
[[Page 55457]]
specified in Table 1 of this proposed AD.
The proposed AD would require you to use the service information
described previously to perform these actions.
Costs of Compliance
We estimate that this proposed AD would affect 260 engines
installed on aircraft of U.S. registry. We also estimate that it would
take 1.0 work-hour per engine to perform the proposed actions, and that
the average labor rate is $80 per work-hour. Required parts would cost
about $8,000 per engine. Based on these figures, we estimate the total
cost of the proposed AD to U.S. operators to be $2,100,800.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to
issue rules on aviation safety. Subtitle I, Section 106, describes the
authority of the FAA Administrator. Subtitle VII, Aviation Programs,
describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in
Subtitle VII, Part A, Subpart III, Section 44701, ``General
requirements.'' Under that section, Congress charges the FAA with
promoting safe flight of civil aircraft in air commerce by prescribing
regulations for practices, methods, and procedures the Administrator
finds necessary for safety in air commerce. This regulation is within
the scope of that authority because it addresses an unsafe condition
that is likely to exist or develop on products identified in this
rulemaking action.
Regulatory Findings
We have determined that this proposed AD would not have federalism
implications under Executive Order 13132. This proposed AD would not
have a substantial direct effect on the States, on the relationship
between the national Government and the States, or on the distribution
of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that the proposed AD:
1. Is not a ``significant regulatory action'' under Executive Order
12866;
2. Is not a ``significant rule'' under the DOT Regulatory Policies
and Procedures (44 FR 11034, February 26, 1979); and
3. Would not have a significant economic impact, positive or
negative, on a substantial number of small entities under the criteria
of the Regulatory Flexibility Act.
We prepared a regulatory evaluation of the estimated costs to
comply with this proposed AD. You may get a copy of this summary at the
address listed under ADDRESSES.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
The Proposed Amendment
Under the authority delegated to me by the Administrator, the
Federal Aviation Administration proposes to amend 14 CFR part 39 as
follows:
PART 39--AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
2. The FAA amends Sec. 39.13 by adding the following new
airworthiness directive:
Honeywell International Inc. (Formerly AlliedSignal, Textron
Lycoming, and Avco Lycoming): Docket No. FAA-2008-1019; Directorate
Identifier 2007-NE-49-AD.
Comments Due Date
(a) The Federal Aviation Administration (FAA) must receive
comments on this airworthiness directive (AD) action by November 24,
2008.
Affected ADs
(b) None.
Applicability
(c) This AD applies to Honeywell International Inc. models
LTS101-600A-2, -600A-3, -600A-3A, -650B-1, -650B-1A, -650C-2, -650C-
3, -650C-3A, -750A-1, -750A-3, -750B-1, -750B-2, and -750C-1
turboshaft engines and LTP101-600A-1A and -700A-1A turboprop engines
with certain gas generator turbine discs, part number (P/N) 4-111-
015-14, installed. These engines are installed on, but not limited
to, Eurocopter France AS350, Eurocopter Deutchland GMBH BK117, and
Bell Helicopter Textron 222 helicopters; and Page Thrush, Air
Tractor AT-302, Industrie Aeronautiche e Meccaniche (formerly
Piaggio & Co.) P166-DL3, Pacific Aero 08-600, and Riley
International R421 airplanes.
Unsafe Condition
(d) This AD results from an error in a change to the engineering
drawing for the gas generator turbine disc from which they
manufactured 260 discs. We are issuing this AD to prevent rupture of
the gas generator turbine disc, which could result in uncontained
engine failure and damage to the aircraft.
Compliance
(e) You are responsible for having the actions required by this
AD performed within the compliance times specified unless the
actions have already been done.
Drawdown Schedule and New Reduced Life Limit for Certain Gas Generator
Turbine Discs
(f) For model LTS101-600A-3 and -750 series turboshaft engines
and model LTP101-600A-1A and -700A-1A turboprop engines that have a
gas generator turbine disc serial number (SN) specified in Appendix
1 of Honeywell International Inc. Service Bulletin (SB) LT 101-71-
00-0002, Revision 25, dated August 31, 2007; remove the engine using
the drawdown schedule specified in Table 1 of this AD.
Table 1--Drawdown Schedule
------------------------------------------------------------------------
If disc cycle
count on the Then remove disc--
Engine model effective date of
this AD is--
------------------------------------------------------------------------
(1) LTS101-600A-3 and -750 (i) Fewer than Before
series turboshaft engines. 4,940 cycles- accumulating
since-new (CSN). 5,040 CSN.
(ii) 4,940 or more Within 100 cycles-
CSN. in-service (CIS)
or 4 months,
whichever occurs
earlier.
(2) LTP101-600A-1A and -700A-1A (i) Fewer than Before
turboprop engines. 2,720 CSN. accumulating
2,770 CSN.
(ii) 2,720 or more Within 50 CIS or 4
CSN. months after the
effective date of
this AD,
whichever occurs
earlier.
------------------------------------------------------------------------
Installation Prohibitions
(g) After the effective date of this AD, don't install any model
LTS101-600A-3 or -750 series turboshaft engine that has a gas
generator turbine disc, P/N 4-111-015-14, with a SN listed in
Appendix 1 of Honeywell International Inc. SB LT 101-71-00-0002,
Revision 25, dated August 31, 2007; if that disc has 5,040 or more
CSN.
[[Page 55458]]
(h) After the effective date of this AD, don't install any model
LTP101-600A-1A or -700A-1A turboprop engine that has a gas generator
turbine disc, P/N 4-111-015-14, with a SN listed in Appendix 1 of
Honeywell International Inc. SB LT 101-71-00-0002, Revision 25,
dated August 31, 2007; if that disc has 2,770 or more CSN.
Alternative Methods of Compliance
(i) The Manager, Los Angeles Aircraft Certification Office, has
the authority to approve alternative methods of compliance for this
AD if requested using the procedures found in 14 CFR 39.19.
Related Information
(j) Honeywell International Inc. Service Bulletin LT 101-71-00-
0002, Revision 25, dated August 31, 2007, pertains to the subject of
this AD.
(k) Contact Robert Baitoo, Aerospace Engineer, Los Angeles
Aircraft Certification Office, FAA, Transport Airplane Directorate,
3960 Paramount Blvd., Lakewood, CA 90712-4137; e-mail:
robert.baitoo@faa.gov; telephone (562) 627-5245; fax (562) 627-5210,
for more information about this AD.
Issued in Burlington, Massachusetts, on September 19, 2008.
Francis A. Favara,
Manager, Engine and Propeller Directorate, Aircraft Certification
Service.
[FR Doc. E8-22522 Filed 9-24-08; 8:45 am]
BILLING CODE 4910-13-P