[Federal Register: November 28, 2008 (Volume 73, Number 230)]
[Rules and Regulations]
[Page 72326-72328]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr28no08-8]
-----------------------------------------------------------------------
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 39
[Docket No. FAA-2008-1244; Directorate Identifier 2008-SW-59-AD;
Amendment 39-15752; AD 2008-22-52]
RIN 2120-AA64
Airworthiness Directives; MD Helicopters, Inc. Model 500N and
600N Helicopters
AGENCY: Federal Aviation Administration, DOT.
ACTION: Final rule; request for comments.
-----------------------------------------------------------------------
SUMMARY: This document supersedes AD 2008-18-52 and publishes in the
Federal Register an amendment adopting Emergency Airworthiness
Directive (AD) 2008-22-52 which was sent previously to all known U.S.
owners and operators of MD Helicopters, Inc. (MDHI) Model 500N and 600N
helicopters by individual letters. This AD requires turning OFF the Yaw
Stability Augmentation System (YSAS); installing a placard that limits
airspeed to 100 KTS or VNE, whichever is less; and revising
the limitations section of the Rotorcraft Flight Manual (RFM) to
reflect that limitation. Finally, replacing the adapter tubes with
airworthy adapter tubes that have a production date code stamp is
required. This AD is prompted by several occurrences of failed adapter
tubes on the Model MD900 helicopter which uses the same adapter tubes.
The actions specified by this AD are intended to prevent loss of yaw
control and subsequent loss of control of the helicopter.
DATES: Effective December 15, 2008, to all persons except those persons
to whom it was made immediately effective by Emergency AD 2008-22-52,
issued on October 23, 2008, which contained the requirements of this
amendment.
Comments for inclusion in the Rules Docket must be received on or
before January 27, 2009.
ADDRESSES: Use one of the following addresses to submit comments on
this AD:
Federal eRulemaking Portal: Go to http://
www.regulations.gov. Follow the instructions for submitting comments.
Fax: 202-493-2251.
Mail: U.S. Department of Transportation, Docket
Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New
Jersey Avenue, SE., Washington, DC 20590.
Hand Delivery: U.S. Department of Transportation, Docket
Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New
Jersey Avenue, SE., Washington, DC 20590, between 9 a.m. and 5 p.m.,
Monday through Friday, except Federal holidays.
You may get the service information identified in this AD from MD
Helicopters Inc., Attn: Customer Support Division, 4555 E. McDowell
Rd., Mail Stop M615, Mesa, Arizona 85215-9734, telephone 1-800-388-
3378, fax 480-346-6813, or on the Web at http://www.mdhelicopters.com.
Examining the Docket: You may examine the docket that contains the
AD, any comments, and other information on the Internet at http://
www.regulations.gov, or in person at the Docket Operations office
between 9 a.m. and 5 p.m., Monday through Friday, except Federal
holidays. The Docket Operations office (telephone (800) 647-5527) is
located in Room W12-140 on the ground floor of the West Building at the
street address stated in the ADDRESSES section. Comments will be
available in the AD docket shortly after receipt.
FOR FURTHER INFORMATION CONTACT: Eric D. Schrieber, FAA, Los Angeles
Aircraft Certification Office, Aviation Safety Engineer, Airframe
Branch, 3960 Paramount Blvd., Lakewood, California 90712, telephone
562-627-5348, fax 562-627-5210.
SUPPLEMENTARY INFORMATION: On August 20, 2008, we issued Emergency AD
2008-18-51 for 500N, 600N, and MD900 helicopters. Emergency AD 2008-18-
51 was prompted by reports that 2 MD900 helicopters experienced failed
vertical stabilizer control system (VSCS) adapter tubes. In one case,
the helicopter experienced an uncommanded yaw, resulting in loss of a
window and a door. The Emergency AD required several actions related to
the YSAS for the Model 500N and 600N helicopters and to the vertical
stabilizer control system (VSCS) for the Model MD900 helicopters.
After we issued Emergency AD 2008-18-51, we discovered that pulling
the circuit breaker per the Emergency AD caused impaired directional
control, which could result in loss of control of the helicopter.
Therefore, on August 27, 2008, we issued superseding Emergency AD 2008-
18-52, which requires, for Model 500N, 600N and MD900 helicopters,
turning OFF the VSCS or YSAS switches instead of pulling the circuit
breakers and installing placards that limit airspeed to 100 KIAS or
VNE, whichever is less. For the Model MD900 helicopters,
limiting flight to VFR, prohibiting use of the autopilot, and making
changes to the Emergency Procedures and Airworthiness (sic) Limitations
sections of the RFM are also required. For all of the helicopter
models, Emergency AD 2008-18-52 requires, within 45 days, terminating
action by replacing the adapter tube with an airworthy adapter tube
that has a date stamp of August 15, 2008 or later, and then removing
the placards, removing the AD limitation changes from the RFM, and
returning all switches and circuit breakers to their normal positions.
Since the issuance of Emergency AD 2008-18-52, we have had
additional occurrences of failed adapter tubes on the MD900
helicopters. The replacement adapter tube that was terminating action
for the requirements of Emergency AD 2008-18-52 failed on 2 of the
MD900 helicopters. Furthermore, adapter tubes without a production date
code stamp remain a safety concern on the 500N and 600N helicopters
because they may not conform to the FAA-approved design. Therefore, we
separated the AD actions and issued 2 superseding Emergency ADs; 2008-
22-52 for the 500N and 600N helicopters, and 2008-22-53 for the MD900
helicopters.
Emergency AD 2008-22-52 applies to the 500N and 600N helicopters
and continues to require the same actions as Emergency AD 2008-18-52;
however,
[[Page 72327]]
we made minor editorial changes as well as the following changes:
We do not include any serial numbers in the applicability
because this unsafe condition can occur on any helicopter with the
affected adapter tube installed.
We require that the limitations section of the RFM be
revised to reflect the airspeed limitation required by the placard.
We require that replacement adapter tubes have a
production date code stamped on them to determine that the parts are
airworthy (e.g., 08-08 indicates a production date of August 2008).
We have reviewed MDHI Service Bulletin (SB) SB500N-040R1/SB600N-
047R1 dated August 27, 2008. The SB specifies de-energizing the YSAS,
installing a placard that limits the airspeed, and replacing the YSAS
adapter.
Since the unsafe condition described is likely to exist or develop
on other MDHI Model 500N and 600N helicopters of the same type designs,
we issued superseding Emergency AD 2008-22-52 to prevent loss of yaw
control and subsequent loss of control of the helicopter. The Emergency
AD requires the following before further flight:
Turning OFF the YSAS switch.
Installing a placard on the instrument panel as close as
practicable to the airspeed indicator that states:
``YSAS SYSTEM IS OFF. AIRSPEED LIMIT 100 KIAS or VNE,
WHICHEVER IS LESS.''
Revising the limitations section of the RFM to limit the
airspeed to 100 KIAS or VNE, whichever is less.
The Emergency AD also requires replacing adapter tubes without a
production date code stamp with adapter tubes that have a production
date code stamp within 45 days and is terminating action for the
requirements of the Emergency AD. After replacing the affected adapter
tubes, the Emergency AD requires removing the placards, removing the
revisions that were made to the RFM because of the Emergency AD, and
returning the YSAS system to its normal position. The short compliance
time involved is required because the previously described critical
unsafe condition can adversely affect the controllability of the
helicopter. Therefore, the actions described previously are required
before further flight and within 45 days, and this AD must be issued
immediately.
Since it was found that immediate corrective action was required,
notice and opportunity for prior public comment thereon were
impracticable and contrary to the public interest, and good cause
existed to make the AD effective immediately by individual letters
issued on October 23, 2008 to all known U.S. owners and operators of
MDHI Model 500N and 600N helicopters. These conditions still exist, and
the AD is hereby published in the Federal Register as an amendment to
14 CFR 39.13 to make it effective to all persons.
We estimate that this AD will affect 65 helicopters of U.S.
registry. The required actions will take about 6 work hours per
helicopter, at an average labor rate of $80 per work hour. Required
parts will cost about $920 per helicopter. Based on these figures we
estimate the total cost impact of the AD on U.S. operators to be
$91,000 ($1,400 per helicopter). However, MDHI states in their service
information that required YSAS adapters will be supplied at no cost and
labor costs of 5.7 hours will be covered under labor warranty. Assuming
operators take advantage of these credits, we estimate that this AD
will have a negligible cost impact on U.S. operators.
Comments Invited
This AD is a final rule that involves requirements that affect
flight safety and was not preceded by notice and an opportunity for
public comment; however, we invite you to submit any written data,
views, or arguments regarding this AD. Send your comments to an address
listed under ADDRESSES. Include ``Docket No. FAA-2008-1244; Directorate
Identifier 2008-SW-59-AD'' at the beginning of your comments. We
specifically invite comments on the overall regulatory, economic,
environmental, and energy aspects of the AD. We will consider all
comments received by the closing date and may amend the AD in light of
those comments.
We will post all comments we receive, without change, to http://
www.regulations.gov, including any personal information you provide. We
will also post a report summarizing each substantive verbal contact
with FAA personnel concerning this AD. Using the search function of our
docket Web site, you can find and read the comments to any of our
dockets, including the name of the individual who sent the comment. You
may review the DOT's complete Privacy Act Statement in the Federal
Register published on April 11, 2000 (65 FR 19477-78).
Regulatory Findings
We have determined that this AD will not have federalism
implications under Executive Order 13132. This AD will not have a
substantial direct effect on the States, on the relationship between
the national Government and the States, or on the distribution of power
and responsibilities among the various levels of government.
For the reasons discussed above, I certify that the regulation:
1. Is not a ``significant regulatory action'' under Executive Order
12866;
2. Is not a ``significant rule'' under the DOT Regulatory Policies
and Procedures (44 FR 11034, February 26, 1979); and
3. Will not have a significant economic impact, positive or
negative, on a substantial number of small entities under the criteria
of the Regulatory Flexibility Act.
We prepared an economic evaluation of the estimated costs to comply
with this AD. See the AD docket to examine the economic evaluation.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to
issue rules on aviation safety. Subtitle I, Section 106, describes the
authority of the FAA Administrator. Subtitle VII, Aviation Programs,
describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in
Subtitle VII, Part A, Subpart III, Section 44701, ``General
requirements.'' Under that section, Congress charges the FAA with
promoting safe flight of civil aircraft in air commerce by prescribing
regulations for practices, methods, and procedures the Administrator
finds necessary for safety in air commerce. This regulation is within
the scope of that authority because it addresses an unsafe condition
that is likely to exist or develop on products identified in this
rulemaking action.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
Adoption of the Amendment
0
Accordingly, pursuant to the authority delegated to me by the
Administrator, the Federal Aviation Administration amends part 39 of
the Federal Aviation Regulations (14 CFR part 39) as follows:
PART 39--AIRWORTHINESS DIRECTIVES
0
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
0
2. Section 39.13 is amended by adding a new airworthiness directive to
read as follows:
[[Page 72328]]
2008-22-52 MD Helicopters, Inc.: Amendment 39-15752. Docket No. FAA-
2008-1244; Directorate Identifier 2008-SW-59-AD. Supersedes
Emergency AD 2008-18-52, Directorate Identifier 2008-SW-52-AD.
Applicability: Model 500N and 600N helicopters, with a Yaw
Stability Augmentation System (YSAS) adapter tube, part number
500N7218-1, installed, certificated in any category. Adapter tubes
that have a production date code stamp are not included in the
applicability of this AD.
Compliance: Required as indicated, unless accomplished
previously.
To prevent loss of yaw control and subsequent loss of control of
the helicopter, do the following:
(a) Before further flight:
(1) Turn OFF the YSAS switch.
(2) Install a placard on the instrument panel as close as
practicable to the airspeed indicator that states:
``YSAS SYSTEM IS OFF. AIRSPEED LIMIT 100 KIAS or VNE,
WHICHEVER IS LESS.''
Note: MDHI Service Bulletin SB500N-040R1/SB600N-047R1, dated
August 27, 2008, and maintenance manual CSP-HMI-3, Section 96-00-00,
pertain to the subject of this AD.
(3) Make pen and ink changes or place a copy of this AD in the
limitations section of the rotorcraft flight manual (RFM) to revise
the limitations as follows: ``VNE is limited to 100 KIAS
or less as determined by referring to the airspeed VNE
placard already installed on the helicopter.''
(b) Within 45 days, replace each affected adapter tube with an
airworthy adapter tube that has a production date code stamp. This
replacement is terminating action for the requirements of this AD.
Once this replacement has been done, remove the placards, remove the
airspeed restriction revisions that were made to the RFM, and return
the YSAS system to its normal position.
(c) To request a different method of compliance or a different
compliance time for this AD, follow the procedures in 14 CFR 39.19.
Contact the Manager, Los Angeles Aircraft Certification Office, FAA,
ATTN: Eric D. Schrieber, Aviation Safety Engineer, Airframe Branch,
3960 Paramount Blvd., Lakewood, California 90712, telephone 562-627-
5348, fax 562-627-5210, for information about previously approved
alternative methods of compliance.
(d) Copies of the applicable service information may be obtained
from MD Helicopters Inc., Attn: Customer Support Division, 4555 E.
McDowell Rd., Mail Stop M615, Mesa, Arizona 85215-9734, telephone 1-
800-388-3378, fax 480-346-6813, or on the Web at http://
www.mdhelicopters.com.
(e) This amendment becomes effective on December 15, 2008, to
all persons except those persons to whom it was made immediately
effective by Emergency AD 2008-22-52, issued October 23, 2008, which
contained the requirements of this amendment.
Issued in Fort Worth, Texas, on November 14, 2008.
Scott A. Horn,
Acting Manager, Rotorcraft Directorate, Aircraft Certification Service.
[FR Doc. E8-28110 Filed 11-26-08; 8:45 am]
BILLING CODE 4910-13-P