[Federal Register: February 27, 2008 (Volume 73, Number 39)]
[Rules and Regulations]
[Page 10379-10380]
From the Federal Register Online via GPO Access [wais.access.gpo.gov]
[DOCID:fr27fe08-1]
========================================================================
Rules and Regulations
Federal Register
________________________________________________________________________
This section of the FEDERAL REGISTER contains regulatory documents
having general applicability and legal effect, most of which are keyed
to and codified in the Code of Federal Regulations, which is published
under 50 titles pursuant to 44 U.S.C. 1510.
The Code of Federal Regulations is sold by the Superintendent of Documents.
Prices of new books are listed in the first FEDERAL REGISTER issue of each
week.
========================================================================
[[Page 10379]]
-----------------------------------------------------------------------
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 25
[Docket No. NM378 Special Conditions No. 25-365-SC]
Special Conditions: Boeing Model 787-8 Airplane; Operation
Without Normal Electrical Power
AGENCY: Federal Aviation Administration (FAA), DOT.
ACTION: Final Special Conditions.
-----------------------------------------------------------------------
SUMMARY: These special conditions are issued for the Boeing Model 787-8
airplane. This airplane will have novel or unusual design features when
compared to the state of technology envisioned in the airworthiness
standards for transport category airplanes. The Boeing Model 787-8
airplane will have numerous electrically operated systems whose
function is needed for continued safe flight and landing of the
airplane. For these design features, the applicable airworthiness
regulations do not contain adequate or appropriate safety standards.
These special conditions contain the additional safety standards that
the Administrator considers necessary to establish a level of safety
equivalent to that established by the existing standards. Additional
special conditions have been issued for other novel or unusual design
features of the Boeing Model 787-8 airplanes.
DATES: Effective Date: March 28, 2008.
FOR FURTHER INFORMATION CONTACT: Stephen Slotte, FAA, Airplane & Flight
Crew Interface Branch, ANM-111, Transport Airplane Directorate,
Aircraft Certification Service, 1601 Lind Avenue, SW., Renton,
Washington 98057-3356; telephone (425) 227-2315; facsimile (425) 227-
1320.
SUPPLEMENTARY INFORMATION:
Background
On March 28, 2003, Boeing applied for an FAA type certificate for
its new Boeing Model 787-8 passenger airplane. The Boeing Model 787-8
airplane will be an all-new, two-engine jet transport airplane with a
two-aisle cabin. The maximum takeoff weight will be 476,000 pounds,
with a maximum passenger count of 381 passengers.
Type Certification Basis
Under provisions of 14 Code of Federal Regulations (CFR) 21.17,
Boeing must show that Boeing Model 787-8 airplanes (hereafter referred
to as ``the 787'') meet the applicable provisions of 14 CFR part 25, as
amended by Amendments 25-1 through 25-117, except Sec. Sec. 25.809(a)
and 25.812, which will remain at Amendment 25-115. If the Administrator
finds that the applicable airworthiness regulations do not contain
adequate or appropriate safety standards for the 787 because of a novel
or unusual design feature, special conditions are prescribed under
provisions of 14 CFR 21.16.
In addition to the applicable airworthiness regulations and special
conditions, the 787 must comply with the fuel vent and exhaust emission
requirements of 14 CFR part 34 and the noise certification requirements
of part 36. The FAA must also issue a finding of regulatory adequacy
pursuant to section 611 of Public Law 92-574, the ``Noise Control Act
of 1972.''
The FAA issues special conditions, as defined in Sec. 11.19, under
Sec. 11.38, and they become part of the type certification basis under
Sec. 21.17(a)(2).
Special conditions are initially applicable to the model for which
they are issued. Should the type certificate for that model be amended
later to include any other model that incorporates the same or similar
novel or unusual design feature, the special conditions would also
apply to the other model under Sec. 21.101.
Novel or Unusual Design Features
The 787 will incorporate a number of novel or unusual design
features, some of which have not been previously installed on large
commercial aircraft. Because of these design features, these special
conditions differ from similar previous special conditions for other
airplane models. Because of rapid improvements in airplane technology,
the applicable airworthiness regulations do not contain adequate or
appropriate safety standards for these design features. These special
conditions for the 787 contain the additional safety standards that the
Administrator considers necessary to establish a level of safety
equivalent to that established by the existing airworthiness standards.
In addition to an electronic flight control system, a number of
systems that have traditionally been pneumatically or mechanically
operated have been implemented as electrically powered systems on the
787. Examples include the hydraulic power, equipment cooling, wing
anti-ice, and auxiliary power unit (APU) and engine start systems. The
criticality of some of these systems is such that their failure would
either reduce the capability of the airplane or the ability of the crew
to cope with adverse operating conditions, or prevent continued safe
flight and landing of the airplane. The airworthiness standards of part
25 do not contain adequate or appropriate standards for protection of
these systems from the adverse effects of operation without normal
electrical power.
The current rule, 14 CFR 25.1351(d), Amendment 25-72, requires safe
operation under visual flight rules (VFR) conditions for at least five
minutes after loss of all normal electrical power. This rule was
structured around traditional airplane designs that used mechanical
control cables and linkages for flight control. These manual controls
allowed the crew to maintain aerodynamic control of the airplane for an
indefinite period of time after loss of all electrical power. Under
those conditions, the mechanical flight control system provided the
crew with the ability to fly the airplane while attempting to identify
the cause of the electrical failure, start the engine(s) if necessary,
and reestablish some of the electrical power generation capability, if
possible.
To maintain the same level of safety associated with traditional
designs, Boeing must design the 787 for operation with the normal
sources of engine- and auxiliary-power-unit (APU)-generated electrical
power not working. Service experience has shown that loss of all
electrical power from the airplane's engine- and APU-driven generators
is not extremely improbable. Thus, Boeing must show that the
[[Page 10380]]
airplane is capable of recovering adequate primary electrical power
generation for safe flight and landing. This demonstration would
provide that the ability to restore operation of portions of the
electrical power generation capability would be considered if
unrecoverable loss of those portions is shown to be extremely
improbable. An alternative source of electrical power would have to be
provided for the time necessary to restore the minimum power generation
capability necessary for safe flight and landing.
Discussion of Comments
Notice of Proposed Special Conditions No. 25-07-11-SC for the 787
was published in the Federal Register on October 16, 2007 (72 FR
58560). No comments were received on this proposal, and we are issuing
these special conditions as proposed.
Applicability
As discussed above, these special conditions are applicable to the
787. Should Boeing apply at a later date for a change to the type
certificate to include another model on the same type certificate
incorporating the same novel or unusual design features, these special
conditions would apply to that model as well.
Conclusion
This action affects only certain novel or unusual design features
of the 787. It is not a rule of general applicability.
List of Subjects in 14 CFR Part 25
Aircraft, Aviation safety, Reporting and recordkeeping
requirements.
0
The authority citation for these special conditions is as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701, 44702, 44704.
The Special Conditions
Accordingly, pursuant to the authority delegated to me by the
Administrator, the following special conditions are issued as part of
the type certification basis for the Boeing Model 787-8 airplane.
In lieu of the requirements of 14 CFR 25.1351(d), the following
special conditions apply:
(1) The applicant must show by test or a combination of test and
analysis that the airplane is capable of continued safe flight and
landing with all normal sources of engine- and auxiliary-power-unit
(APU)-generated electrical power inoperative, as prescribed by
paragraphs (1)(a) and (1)(b) below. For purposes of this special
condition, normal sources of electrical power generation do not include
any alternate power sources such as the battery, ram air turbine (RAT),
or independent power systems such as the flight control permanent
magnet generating system. In showing capability for continued safe
flight and landing, consideration must be given to systems capability,
effects on crew workload and operating conditions, and the
physiological needs of the flightcrew and passengers for the longest
diversion time for which approval is sought.
(a) Common cause failures, cascading failures, and zonal physical
threats must be considered in showing compliance with this requirement.
(b) In showing compliance with this requirement, the ability to
restore operation of portions of the electrical power generation and
distribution system may be considered if it can be shown that
unrecoverable loss of those portions of the system is extremely
improbable. An alternative source of electrical power must be provided
for the time required to restore the minimum electrical power
generation capability required for safe flight and landing.
(Unrecoverable loss of all engines may be excluded when showing that
unrecoverable loss of critical portions of the electrical system is
extremely improbable.)
(2) Regardless of any electrical generation and distribution system
recovery capability shown under paragraph 1, sufficient electrical
system capability must be provided--
(a) to allow time to descend, with all engines inoperative, at the
speed that provides the best glide slope, from the maximum operating
altitude to the altitude at which the soonest possible engine restart
could be accomplished, and
(b) to subsequently allow multiple start attempts of the engines
and APU. This capability must be provided in addition to the electrical
capability required by existing part 25 requirements related to
operation with all engines inoperative.
(3) The electrical energy used by the airplane in descending with
engines inoperative from the maximum operating altitude at the best
glide slope, and in making multiple attempts to start the engines and
APU, must be considered when showing compliance with paragraphs (1) and
(2) of these special conditions and with existing 14 CFR part 25
requirements related to continued safe flight and landing.
Issued in Renton, Washington, on February 13, 2008.
Stephen P. Boyd,
Acting Manager, Transport Airplane Directorate, Aircraft Certification
Service.
[FR Doc. E8-3714 Filed 2-26-08; 8:45 am]
BILLING CODE 4910-13-P