[Federal Register Volume 76, Number 17 (Wednesday, January 26, 2011)]
[Proposed Rules]
[Pages 4567-4569]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 2011-1438]
=======================================================================
-----------------------------------------------------------------------
DEPARTMENT OF TRANSPORTATION
Federal Aviation Administration
14 CFR Part 39
[Docket No. FAA-2011-0032; Directorate Identifier 2010-NM-236-AD]
RIN 2120-AA64
Airworthiness Directives; The Boeing Company Model 737-600, -700,
-700C, -800, and -900 Series Airplanes
AGENCY: Federal Aviation Administration (FAA), DOT.
ACTION: Notice of proposed rulemaking (NPRM).
-----------------------------------------------------------------------
SUMMARY: We propose to adopt a new airworthiness directive (AD) for the
products listed above. This proposed AD would require an inspection of
the orientation of both sides of the coil cord connector keyways of the
number 2 windows on the flight deck, re-clocking the connector keyways
to 12 o'clock if necessary; and replacing the coil cord assemblies on
both number 2 windows on the flight deck. This proposed AD was prompted
by reports of arcing and smoke at the number 2 window in the flight
deck. We are proposing this AD to prevent arcing, smoke, and fire in
the flight deck, which could lead to injuries to or incapacitation of
the flight crew.
DATES: We must receive comments on this proposed AD by March 14, 2011.
ADDRESSES: You may send comments by any of the following methods:
Federal eRulemaking Portal: Go to http://www.regulations.gov. Follow the instructions for submitting comments.
Fax: 202-493-2251.
Mail: U.S. Department of Transportation, Docket
Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New
Jersey Avenue, SE., Washington, DC 20590.
Hand Delivery: Deliver to Mail address above between 9
a.m. and 5 p.m., Monday through Friday, except Federal holidays.
For service information identified in this proposed AD, contact
Boeing Commercial Airplanes, Attention: Data & Services Management,
P.O. Box 3707, MC 2H-65, Seattle, Washington 98124-2207; telephone 206-
544-5000, extension 1; fax 206-766-5680; e-mail [email protected];
Internet https://www.myboeingfleet.com. You may review copies of the
referenced service information at the FAA, Transport Airplane
Directorate, 1601 Lind Avenue, SW., Renton, Washington. For information
on the availability of this material at the FAA, call 425-227-1221.
Examining the AD Docket
You may examine the AD docket on the Internet at http://www.regulations.gov; or in person at the Docket Management Facility
between 9 a.m. and 5 p.m., Monday through Friday, except Federal
holidays. The AD docket contains this proposed AD, the regulatory
evaluation, any comments received, and other information. The street
address for the Docket Office (phone: 800-647-5527) is in the ADDRESSES
section. Comments will be available in the AD docket shortly after
receipt.
FOR FURTHER INFORMATION CONTACT: Louis Natsiopoulos, Aerospace
Engineer, Systems and Equipment Branch, ANM-130S, FAA, Seattle Aircraft
Certification Office; phone: 425-917-6478; fax: 425-917-6590; e-mail:
[email protected].
SUPPLEMENTARY INFORMATION:
Comments Invited
We invite you to send any written relevant data, views, or
arguments about this proposal. Send your comments to an address listed
under the ADDRESSES section. Include ``Docket No. FAA-2011-0032;
Directorate Identifier 2010-NM-236-AD'' at the beginning of your
comments. We specifically invite comments on the overall regulatory,
economic, environmental, and energy aspects of this proposed AD. We
will consider all comments received by the closing date and may amend
this proposed AD because of those comments.
We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We
will also post a report summarizing each substantive verbal contact we
receive about this proposed AD.
Discussion
We received a report of arcing and smoke at the left number 2
window in the flight deck. The arcing and smoke were traced to
mechanical damage of the heat-coil assembly at the 90-degree connector
back shell. It appears that the wires are being stressed at the back
shell when the window is cycled open and closed. The repeated cycles
are causing the wires to fatigue and break resulting in arcing, smoke,
and fire in the flight deck. This condition, if not corrected, could
lead to injuries to or incapacitation of the flight crew.
Relevant Service Information
We reviewed Boeing Special Attention Service Bulletin 737-30-1058,
Revision 3, dated July 7, 2010. The service information describes
procedures for inspecting the orientation of both sides of the coil
cord connector keyways, re-clocking the connector keyways to the 12
o'clock position if necessary; and replacing the existing coil cord
assemblies with new assemblies on both sides of the flight deck.
FAA's Determination
We are proposing this AD because we evaluated all the relevant
information and determined the unsafe condition described previously is
likely to exist or develop in other products of the same type designs.
Proposed AD Requirements
This proposed AD would require accomplishing the actions specified
in the service information described previously.
Costs of Compliance
We estimate that this proposed AD will affect 687 airplanes of U.S.
registry.
We estimate the following costs to comply with this proposed AD:
[[Page 4568]]
Estimated costs
--------------------------------------------------------------------------------------------------------------------------------------------------------
Action Labor cost Parts cost Cost per product Cost on U.S. operators
--------------------------------------------------------------------------------------------------------------------------------------------------------
Keyway inspection and installation of new 6 work-hours x $85 per hour = $1,608 $2,118 $1,455,066
cord assemblies on both sides of the $510.
flight deck.
--------------------------------------------------------------------------------------------------------------------------------------------------------
According to the manufacturer, some of the costs of this proposed
AD may be covered under warranty, thereby reducing the cost impact on
affected individuals. We do not control warranty coverage for affected
individuals. As a result, we have included all costs in our cost
estimate.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to
issue rules on aviation safety. Subtitle I, section 106, describes the
authority of the FAA Administrator. Subtitle VII: Aviation Programs,
describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in
subtitle VII, part A, subpart III, section 44701: ``General
requirements.'' Under that section, Congress charges the FAA with
promoting safe flight of civil aircraft in air commerce by prescribing
regulations for practices, methods, and procedures the Administrator
finds necessary for safety in air commerce. This regulation is within
the scope of that authority because it addresses an unsafe condition
that is likely to exist or develop on products identified in this
rulemaking action.
Regulatory Findings
We determined that this proposed AD would not have federalism
implications under Executive Order 13132. This proposed AD would not
have a substantial direct effect on the States, on the relationship
between the national Government and the States, or on the distribution
of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify this proposed
regulation:
(1) Is not a ``significant regulatory action'' under Executive
Order 12866,
(2) Is not a ``significant rule'' under the DOT Regulatory Policies
and Procedures (44 FR 11034, February 26, 1979),
(3) Will not affect intrastate aviation in Alaska, and
(4) Will not have a significant economic impact, positive or
negative, on a substantial number of small entities under the criteria
of the Regulatory Flexibility Act.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Incorporation by
reference, Safety.
The Proposed Amendment
Accordingly, under the authority delegated to me by the
Administrator, the FAA proposes to amend 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
2. The FAA amends Sec. 39.13 by adding the following new
airworthiness directive (AD):
The Boeing Company: Docket No. FAA-2011-0032; Directorate Identifier
2010-NM-236-AD.
Comments Due Date
(a) We must receive comments by March 14, 2011.
Affected ADs
(b) None.
Applicability
(c) This AD applies to The Boeing Company Model 737-600, -700, -
700C, -800, and -900 series airplanes, certificated in any category,
as identified in Boeing Special Attention Service Bulletin 737-30-
1058, Revision 3, dated July 7, 2010.
Subject
(d) Joint Aircraft System Component (JASC)/Air Transport
Association (ATA) of America Code 30, Ice and Rain Protection.
Unsafe Condition
(e) This AD was prompted by reports of arcing and smoke at the
left number 2 window in the flight deck. We are issuing this AD to
prevent arcing, smoke, and fire in the flight deck, which could lead
to injuries to or incapacitation of the flight crew.
Compliance
(f) Comply with this AD within the compliance times specified,
unless already done.
Replacement
(g) Within 48 months after the effective date of this AD, do the
actions in paragraphs (g)(1) and (g)(2) of this AD.
(1) Do a general visual inspection of the orientation of the
coil cord connector keyways on the captain's and first officer's
side of the flight compartment, in accordance with the
Accomplishment Instructions of Boeing Special Attention Service
Bulletin 737-30-1058, Revision 3, dated July 7, 2010. If the
orientation is not at the 12 o'clock position, before further
flight, re-clock the connector keyways to the 12 o'clock position,
in accordance with the Accomplishment Instructions of Boeing Special
Attention Service Bulletin 737-30-1058, Revision 3, dated July 7,
2010.
(2) Replace the coil cord assemblies with new assemblies on both
sides of the flight deck, in accordance with the Accomplishment
Instructions of Boeing Special Attention Service Bulletin 737-30-
1058, Revision 3, dated July 7, 2010.
Credit for Actions Accomplished in Accordance With Previous Service
Information
(h) Actions done before the effective date of this AD, in
accordance with a service bulletin identified in table 1 of this AD,
are acceptable for compliance with the corresponding actions
specified in this AD.
Table 1--Acceptable Previous Service Information
----------------------------------------------------------------------------------------------------------------
Boeing Service Bulletin Revision Dated
----------------------------------------------------------------------------------------------------------------
737-30-1058......................... Original............................ July, 27, 2006.
737-30-1058......................... 1................................... June 18, 2007.
737-30-1058......................... 2................................... February 13, 2009.
----------------------------------------------------------------------------------------------------------------
[[Page 4569]]
Alternative Methods of Compliance (AMOCs)
(i)(1) The Manager, Seattle Aircraft Certification Office, FAA,
has the authority to approve AMOCs for this AD, if requested using
the procedures found in 14 CFR 39.19. In accordance with 14 CFR
39.19, send your request to your principal inspector or local Flight
Standards District Office, as appropriate. If sending information
directly to the manager of the ACO, send it to the attention of the
person identified in the Related Information section of this AD.
Information may be e-mailed to: [email protected].
(2) Before using any approved AMOC, notify your appropriate
principal inspector, or lacking a principal inspector, the manager
of the local flight standards district office/certificate holding
district office.
Related Information
(j) For more information about this AD, contact Louis
Natsiopoulos, Aerospace Engineer, Systems and Equipment Branch, ANM-
130S, FAA, Seattle Aircraft Certification Office (ACO); phone: 425-
917-6478; fax: 425-917-6590; e-mail: [email protected].
(k) For service information identified in this AD, contact
Boeing Commercial Airplanes, Attention: Data & Services Management,
P.O. Box 3707, MC 2H-65, Seattle, Washington 98124-2207; telephone
206-544-5000, extension 1; fax 206-766-5680; e-mail
[email protected]; Internet https://www.myboeingfleet.com. You
may review copies of the referenced service information at the FAA,
Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton,
Washington. For information on the availability of this material at
the FAA, call 425-227-1221.
Issued in Renton, Washington, on January 12, 2011.
Jeffrey E. Duven,
Acting Manager, Transport Airplane Directorate, Aircraft Certification
Service.
[FR Doc. 2011-1438 Filed 1-25-11; 8:45 am]
BILLING CODE 4910-13-P