[Code of Federal Regulations] [Title 40, Volume 27] [Revised as ofJuly 1, 2003] From the U.S. Government Printing Office via GPO Access [CITE: 40CFR471.45] [Page 735-738] TITLE 40--PROTECTION OF ENVIRONMENT CHAPTER I--ENVIRONMENTAL PROTECTION AGENCY (CONTINUED) PART 471--NONFERROUS METALS FORMING AND METAL POWDERS POINT SOURCE CATEGORY--Table of Contents Subpart D--Precious Metals Forming Subcategory Sec. 471.45 Pretreatment standards for new sources (PSNS). Except as provided in 40 CFR 403.7, any new source subject to this subpart which introduces pollutants into a publicly owned treatment works must comply with 40 CFR part 403 and achieve the following pretreatment [[Page 736]] standards for new sources (PSNS). The mass of wastewater pollutants in precious metals forming wastewater introduced into a POTW shall not exceed the following values: (a) Rolling spent neat oils--Subpart D--PSNS. There shall be no discharge of process wastewater pollutants. (b) Rolling spent emulsions. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals rolled with emulsions --------------- Cadmium..................................... 0.026 0.012 Copper...................................... 0.147 0.077 Cyanide..................................... 0.023 0.010 Silver...................................... 0.032 0.013 ------------------------------------------------------------------------ (c) Drawing spent neat oils--Subpart D--PSNS. There shall be no discharge of process wastewater pollutants. (d) Drawing spent emulsions. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals drawn with emulsions --------------- Cadmium..................................... 0.016 0.007 Copper...................................... 0.091 0.048 Cyanide..................................... 0.014 0.006 Silver...................................... 0.020 0.008 ------------------------------------------------------------------------ (e) Drawing spent soap solutions. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals drawn with soap solutions --------------- Cadmium..................................... 0.001 0.0005 Copper...................................... 0.006 0.003 Cyanide..................................... 0.0009 0.0004 Silver...................................... 0.002 0.0006 ------------------------------------------------------------------------ (f) Metal powder production wet atomization wastewater. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals powder wet atomized --------------- Cadmium..................................... 2.27 1.00 Copper...................................... 12.7 6.68 Cyanide..................................... 1.94 0.802 Silver...................................... 2.74 1.14 ------------------------------------------------------------------------ (g) Heat treatment contact cooling water. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of extended precious metals heat treated --------------- Cadmium..................................... 0.142 0.063 Copper...................................... 0.793 0.417 Cyanide..................................... 0.121 0.050 Silver...................................... 0.171 0.071 ------------------------------------------------------------------------ (h) Semi-continuous and continuous casting contact cooling water. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals cast by the semi-continuous or continuous method --------------- Cadmium..................................... 0.350 0.155 Copper...................................... 1.96 1.03 Cyanide..................................... 0.299 0.124 Silver...................................... 0.423 0.175 ------------------------------------------------------------------------ (i) Stationary casting contact cooling water--Subpart D--PSNS. There shall be no discharge of process wastewater pollutants. (j) Direct chill casting contact cooling water. [[Page 737]] Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals cast by the direct chill method --------------- Cadmium..................................... 0.367 0.162 Copper...................................... 2.05 1.08 Cyanide..................................... 0.313 0.130 Silver...................................... 0.443 0.184 ------------------------------------------------------------------------ (k) Shot casting contact cooling water. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals shot cast --------------- Cadmium..................................... 0.125 0.055 Copper...................................... 0.698 0.367 Cyanide..................................... 0.107 0.044 Silver...................................... 0.151 0.0631 ------------------------------------------------------------------------ (l) Wet air pollution control scrubber blowdown--Subpart D--PSNS. There shall be no discharge of process wastewater pollutants. (m) Pressure bonding contact cooling water. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals and base metal pressure bonded --------------- Cadmium..................................... 0.029 0.013 Copper...................................... 0.159 0.084 Cyanide..................................... 0.024 0.010 Silver...................................... 0.034 0.014 ------------------------------------------------------------------------ (n) Surface treatment spent baths. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals surface treated --------------- Cadmium..................................... 0.033 0.015 Copper...................................... 0.183 0.097 Cyanide..................................... 0.028 0.012 Silver...................................... 0.040 0.017 ------------------------------------------------------------------------ (o) Surface treatment rinse. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals surface treated --------------- Cadmium..................................... 0.210 0.093 Copper...................................... 1.17 0.616 Cyanide..................................... 0.179 0.074 Silver...................................... 0.253 0.105 ------------------------------------------------------------------------ (p) Alkaline cleaning spent baths. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals alkaline cleaned --------------- Cadmium..................................... 0.021 0.009 Copper...................................... 0.114 0.060 Cyanide..................................... 0.018 0.007 Silver...................................... 0.025 0.010 ------------------------------------------------------------------------ (q) Alkaline cleaning rinse. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals alkaline cleaned --------------- Cadmium..................................... 0.381 0.168 Copper...................................... 2.13 1.12 Cyanide..................................... 0.325 0.135 Silver...................................... 0.459 0.191 ------------------------------------------------------------------------ (r) Alkaline cleaning pre-bonding wastewater. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals and base metal cleaned prior to bonding --------------- Cadmium..................................... 0.400 0.174 Copper...................................... 2.21 1.16 Cyanide..................................... 0.337 0.139 Silver...................................... 0.476 0.197 ------------------------------------------------------------------------ (s) Tumbling or burnishing wastewater. [[Page 738]] Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals tumbled or burnished --------------- Cadmium..................................... 0.412 0.182 Copper...................................... 2.30 1.21 Cyanide..................................... 0.351 0.145 Silver...................................... 0.496 0.206 ------------------------------------------------------------------------ (t) Sawing or grinding spent neat oils--Subpart D--PSNS. There shall be no discharge of process wastewater pollutants. (u) Sawing or grinding spent emulsions. Subpart D--PSNS ------------------------------------------------------------------------ Maximum for Pollutant or pollutant property Maximum for monthly any 1 day average ------------------------------------------------------------------------ mg/off-kg (pounds per million off-pounds) of precious metals sawed or ground with emulsions -------------- Cadmium....................................... 0.032 0.014 Copper........................................ 0.178 0.094 Cyanide....................................... 0.027 0.011 Silver........................................ 0.038 0.016 ------------------------------------------------------------------------ (v) Degreasing spent solvents--Subpart D--PSNS. There shall be no discharge of process wastewater pollutants. [50 FR 34270, Aug. 23, 1985; 51 FR 2886, Jan. 22, 1986]