[Code of Federal Regulations] [Title 49, Volume 2] [Revised as of October 1, 2003] From the U.S. Government Printing Office via GPO Access [CITE: 49CFR174.81] [Page 645-648] TITLE 49--TRANSPORTATION CHAPTER I--RESEARCH AND SPECIAL PROGRAMS ADMINISTRATION, DEPARTMENT OF TRANSPORTATION PART 174_CARRIAGE BY RAIL--Table of Contents Subpart C_General Handling and Loading Requirements Sec. 174.81 Segregation of hazardous materials. (a) This section applies to materials which meet one or more of the hazard classes defined in this subchapter and are in packages which are required to be labeled or placarded under the provisions of part 172 of this subchapter. (b) When a rail car is to be transported by vessel, other than a ferry vessel, hazardous materials on or within that rail car must be stowed and segregated in accordance with Sec. 176.83(b) of this subchapter. (c) In addition to the provisions of paragraph (d) of this section, cyanides or cyanide mixtures may not be loaded or stored with acids. (d) Hazardous materials may not be loaded, transported, or stored together, except as provided in this section, and in accordance with the following table: [[Page 646]] Segregation Table for Hazardous Materials ------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------ 6.1 1.1, 2.3 gas 2.3 gas liquids 8 liquids Class or Division Notes 1.2 1.3 1.4 1.5 1.6 2.1 2.2 Zone A Zone B 3 4.1 4.2 4.3 5.1 5.2 PG I Zone 7 only A ------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------ Explosives.................... 1.1 and A * * * * * X X X X X X X X X X X X X 1.2 Explosives.................... 1.3 ......... * * * * * X ..... X X X ..... X X X X X ..... X Explosives.................... 1.4 ......... * * * * * O ..... O O O ..... O ..... ..... ..... O ..... O Very insensitive explosives... 1.5 A * * * * * X X X X X X X X X X X X X Extremely insensitive 1.6 ......... * * * * * ..... ..... ......... ......... ..... ..... ..... ..... ..... ..... ......... ..... ......... explosives. Flammable gases............... 2.1 ......... X X O X ..... ..... ..... X O ..... ..... ..... ..... ..... ..... O O ......... Non-toxic, non-flammable gases 2.2 ......... X ..... ..... X ..... ..... ..... ......... ......... ..... ..... ..... ..... ..... ..... ......... ..... ......... Poisonous gas Zone A.......... 2.3 ......... X X O X ..... X ..... ......... ......... X X X X X X ......... ..... X Poisonous gas Zone B.......... 2.3 ......... X X O X ..... O ..... ......... ......... O O O O O O ......... ..... O Flammable liquids............. 3 ......... X X O X ..... ..... ..... X O ..... ..... ..... ..... O ..... X ..... ......... Flammable solids.............. 4.1 ......... X ..... ..... X ..... ..... ..... X O ..... ..... ..... ..... ..... ..... X ..... O Spontaneously combustible 4.2 ......... X X O X ..... ..... ..... X O ..... ..... ..... ..... ..... ..... X ..... X materials. Dangerous when wet materials.. 4.3 ......... X X ..... X ..... ..... ..... X O ..... ..... ..... ..... ..... ..... X ..... O Oxidizers..................... 5.1 A X X ..... X ..... ..... ..... X O O ..... ..... ..... ..... ..... X ..... O Organic peroxides............. 5.2 ......... X X ..... X ..... ..... ..... X O ..... ..... ..... ..... ..... ..... X ..... O Poisonous liquids PG I Zone A. 6.1 ......... X X O X ..... O ..... ......... ......... X X X X X X ......... ..... X Radioactive materials......... 7 ......... X ..... ..... X ..... O ..... ......... ......... ..... ..... ..... ..... ..... ..... ......... ..... ......... Corrosive liquids............. 8 ......... X X O X ..... ..... ..... X O ..... O X O O O X ..... ......... ------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------ [[Page 647]] (e) Instructions for using the segregation table for hazardous materials in paragraph (d) of this section are as follows: (1) The absence of any hazard class or division, or a blank space in the table indicates that no restrictions apply. (2) The letter ``X'' in the table indicates that these materials may not be loaded, transported, or stored together in the same rail car or storage facility during the course of transportation. (3) The letter ``O'' in the table indicates that these materials may not be loaded, transported, or stored together in the same rail car or storage facility during the course of transportation unless separated in a manner that, in the event of leakage from packages under conditions normally incident to transportation, commingling of hazardous materials would not occur. Notwithstanding the methods of separation employed, Class 8 (corrosive) liquids may not be loaded above or adjacent to Class 4 (flammable) or Class 5 (oxidizing) materials; except that shippers may load carload shipments of such materials together when it is known that the mixture of contents would not cause a fire or a dangerous evolution of heat or gas. (4) The ``*'' in the table indicates that segregation among different Class 1 (explosive) materials is governed by the compatibility table in paragraph (f) of this section. (5) The note ``A'' in the second column of the table means that, notwithstanding the requirements of the letter ``X'', ammonium nitrate fertilizer may be loaded or stored with Division 1.1 (explosive) or Division 1.5 materials. (6) When the Sec. 172.101 table or Sec. 172.402 of this subchapter requires a package to bear a subsidiary hazard label, segregation appropriate to the subsidiary hazard must be applied when that segregation is more restrictive than that required by the primary hazard. However, hazardous materials of the same class may be loaded and transported together without regard to segregation required by any secondary hazard if the materials are not capable of reacting dangerously with each other and causing combustion or dangerous evolution of heat, evolution of flammable, poisonous, or asphyxiant gases, or formation of corrosive or unstable materials. (f) Class 1 (explosive) materials may not be loaded, transported, or stored together, except as provided in this section, and in accordance with the following table: Compatibility Table For Class 1 (Explosive) Materials ---------------------------------------------------------------------------------------------------------------- Compatibility group A B C D E F G H J K L N S ---------------------------------------------------------------------------------------------------------------- A.............................................. ... X X X X X X X X X X X X B.............................................. X ... X 4 X X X X X X X X 4/5 C.............................................. X X ... 2 2 X 6 X X X X 3 4/5 D.............................................. X 4 2 ... 2 X 6 X X X X 3 4/5 E.............................................. X X 2 2 ... X 6 X X X X 3 4/5 F.............................................. X X X X X ... X X X X X X 4/5 G.............................................. X X 6 6 6 X ... X X X X X 4/5 H.............................................. X X X X X X X ... X X X X 4/5 J.............................................. X X X X X X X X ... X X X 4/5 K.............................................. X X X X X X X X X ... X X 4/5 L.............................................. X X X X X X X X X X 1 X X N.............................................. X X 3 3 3 X X X X X X ... 4/5 S.............................................. X 4/5 4/5 4/5 4/5 4/5 4/5 4/5 4/5 4/5 X 4/5 ... ---------------------------------------------------------------------------------------------------------------- (g) Instructions for using the compatibility table for Class 1 (explosive) materials in paragraph (f) of this section are as follows: (1) A blank space in the table indicates that no restrictions apply. (2) The letter ``X'' in the table indicates that explosives of different compatibility groups may not be carried on the same rail car, unless packed in separate freight containers (e.g., two or more freight containers mounted upon the same rail car). (3) The numbers in the table mean the following: (i) ``1'' means explosives from compatibility group L may only be carried [[Page 648]] on the same rail car with an identical explosive. (ii) ``2'' means any combination of explosives from compatibility group C, D, or E is assigned to compatibility group E. (iii) ``3'' means any combination of explosives from compatibility group C, D, or E with those in compatibility group N is assigned to compatibility group D. (iv) ``4'' means detonators and detonating primers, Division 1.4S (explosives), may not be loaded in the same car with Division 1.1 and 1.2 (explosive) materials. (v) ``5'' means Division 1.4S fireworks may not be loaded in the same car with Division 1.1 or 1.2 (explosive) materials. (vi) ``6'' means explosive articles in compatibility group G, other than fireworks and those requiring special stowage, may be loaded and transported with articles of compatibility groups C, D and E, provided no explosive substances are carried in the same rail car. (h) Except as provided in paragraph (i) of this section, explosives of the same compatibility group but of different divisions may be transported together provided that the whole shipment is transported as though its entire contents were of the lower numerical division (i.e., Division 1.1 being lower than Division 1.2). For example, a mixed shipment of Division 1.2 (explosive) materials and Division 1.4 (explosive) materials, compatibility group D, must be transported as Division 1.2 (explosive) materials. (i) When Division 1.5 materials, compatibility group D are transported in the same freight container as Division 1.2 (explosive) materials, compatibility group D, the shipment must be transported as Division 1.1 (explosive) materials, compatibility group D. [Amdt. 174-68, 55 FR 52678, Dec. 21, 1990, as amended at 56 FR 66280- 66281, Dec. 20, 1991; 57 FR 45464, Oct. 1, 1992; Amdt. 174-68, 57 FR 59310, Dec. 15, 1992; Amdt. 174-75, 58 FR 50237, Sept. 24, 1993; Amdt. 174-83, 61 FR 51339, Oct. 1, 1996; 64 FR 10781, Mar. 5, 1999; 66 FR 45383, Aug. 28, 2001; 67 15743, Apr. 3, 2002]