[Code of Federal Regulations] [Title 29, Volume 3] [Revised as of July 1, 2005] From the U.S. Government Printing Office via GPO Access [CITE: 29CFR782.6] [Page 595-598] TITLE 29--LABOR CHAPTER V--WAGE AND HOUR DIVISION, DEPARTMENT OF LABOR PART 782_EXEMPTION FROM MAXIMUM HOURS PROVISIONS FOR CERTAIN EMPLOYEES OF MOTOR CARRIERS--Table of Contents Sec. 782.6 Mechanics. (a) A ``mechanic,'' for purposes of safety regulations under the Motor Carrier Act is an employee who is employed by a carrier subject to the Secretary's jurisdiction under section 204 of the Motor Carrier Act and whose duty it is to keep motor vehicles operated in interstate or foreign commerce by his employer in a good and safe working condition. (Ex parte, Nos. MC-2 and MC-3, 28 M.C.C. 125, 132, 133. Ex parte No. MC- 40 (Sub. No. 2), 88 M.C.C. 710 (repair of refrigeration equipment). See also Morris v. McComb, 332 U.S. 422.) It has been determined that the safety of operation of such motor vehicles on the highways is directly affected by those activities of mechanics, such as keeping the lights and brakes in a good and safe working condition, which prevent the vehicles from becoming potential hazards to highway safety and thus aid in the prevention of accidents. The courts have held that mechanics perform work of this character where they actually do inspection, adjustment, repair or maintenance work on the motor vehicles themselves (including trucks, tractors and trailers, and buses) and are, when so engaged, directlyresponsible for creating or maintaining physical conditions essential to the safety [[Page 596]] of the vehicles on the highways through the correction or prevention of defects which have a direct causal connection with the safe operation of the unit as a whole. (Walling v. Silver Bros., 136 F. (2d) 168 (C.A. 1); McDuffie v. Hayes Freight Lines, 71 F. Supp. 755; Walling v. Silver Fleet Motor Express, 67 F. Supp. 846; Keeling v. Huber & Huber Motor Express, 57 F. Supp. 617; Walling v. Huber & Huber Motor Express, 67 F. Supp. 855; Tinerella v. Des Moines Transp. Co., 41 F. Supp. 798; Robbins v. Zabarsky, 44 F. Supp. 867; West V. Smoky Mt. Stages, 40 F. Supp. 296; Walling v. Cumberland & Liberty Mills Co. (S.D. Fla.), 6 Labor Cases, par. 61,184; Esibill v. Marshall (D. N.J.), 6 Labor Cases, par. 61,256; Keegan v. Ruppert (S.D. N.Y.), 7 Labor Cases, par. 61,726; Baker v. Sharpless Hendler Ice Cream Co. (E.D. Pa.), 10 Labor Cases, par. 62,956; Kentucky Transport Co. v. Drake (Ky. Ct. App.). 182 SW (2d) 960.) The following activities performed by mechanics on motor vehicles operated in interstate orforeign commerce are illustrative of the specific kinds of activities which the courts, in applying the foregoing principles, have regarded as directly affecting ``safety of operation'': The inspection, repair, adjustment, and maintenance for safe operation of steering apparatus, lights, brakes, horns, windshield wipers, wheels and axles, bushings, transmissions, differentials, motors, starters and ignition, carburetors, fifth wheels, springs and spring hangers, frames, and gasoline tanks (McDuffie v. Hayes Freight Lines, 71 F. Supp. 755; Walling v. Silver Fleet Motor Express, 67 F. Supp. 846; Wolfe v. Union Transfer & Storage Co., 48 F. Supp. 855; Mason & Dixon Lines v. Ligon (Tenn. Ct. App.) 7 Labor Cases, par. 61,962; Walling v. Palmer, 67 F. Supp. 12; Kentucky Transport Co. v. Drake (Ky. Ct. App.), 182 SW (2d) 960.) Inspecting and checking air pressure in tires, changing tires, and repairing and rebuilding tires for immediate replacement on the vehicle from which they were removed have also been held to affect safety of operation directly. (Walling v. Silver Fleet Motor Express, 67 F. Supp. 846; Walling v. Palmer, 67 F. Supp. 12. See also McDuffie v. Hayes Freight Lines, 71 F. Supp. 755.) The same is true of hookingup tractors and trailers, including light and brake connections, and the inspection of such hookups. (Walling v. Silver Fleet Motor Express, 67 F. Supp. 846; Walling v. Palmer, 67 F. Supp. 12. See also Walling v. Gordon's Transports (W.D. Tenn.). 10 Labor cases, par. 62,934, affirmed 162 F. (2d) 203 (C.A. 6), certiorari denied 332 U.S. 744.) (b) The section 13(b)(1) exemption applies, in accordance with principles previously stated (see Sec. 782.2), to an employee whose job involves activities consisting wholly or in part of doing, or immediately directing, a class of work which, under the definitions referred to above, is that of a ``mechanic'' and directly affects the safety of operation of motor vehicles on the public highways in interstate or foreign commerce, within the meaning of the Motor Carrier Act. The power under the Motor Carrier Act to establish qualifications and maximum hours of service for such an employee has been sustained by the courts. (Morris v. McComb, 332 U.S. 422. See also Pyramid Motor Freight Corp. v. Ispass. 330 U.S. 695; Levinson v. Spector Motor Service, 330 U.S. 649; Walling v. Silver Bros., 136 F. (2d) 168 (C.C.A. 1)). A supervisory employee who plans and immediately directs and checks the proper performance of this class of workmay come within the exemption as a partial-duty mechanic. (Robbins v. Zabarsky, 44 F. Supp. 867; Mason & Dixon Lines v. Ligon (Tenn. Ct. App.), 7 Labor Cases par. 61,962; cf. Morris v. McComb, 332 U.S. 422 and Levinson v. Spector Motor Service, 330 U.S. 649) (c)(1) An employee of a carrier by motor vehicle is not exempted as a ``mechanic'' from the overtime provisions of the Fair Labor Standards Act under section 13(b)(1) merely because he works in the carrier's gargage, or because he is called a ``mechanic,'' or because he is a mechanic by trade and does mechanical work. (Wirtz v. Tyler Pipe & Foundry Co., 369 F. 2d 927 (C.A. 5).) The exemption applies only if he is doing a class of work defined as that of a ``mechanic'', including activities which directly affect the safety of operation of motor vehicles in transporation on the public highways in interstate or foreign commerce. (Morris v. McComb, 332 U.S. 422; Keeling v. Huber & Huber Motor Express, 57 F. [[Page 597]] Supp. 617; Walling v. Huber & Huber Motor Express, 67 F. Supp. 855; Walling v. Silver Fleet Motor Express, 67 F. Supp.846; McDuffie v. Hayes Freight Lines, 71 F. Supp. 755; Anuchick v. Transamerican Freight Lines, 46 F. Supp. 861; Walling v. Burlington Transp. Co. (D. Nebr.), 9 Labor Cases, par. 62,576. Compare Ex parte No. MC-40 (Sub. No. 2), 88 M.C.C. 710 with Colbeck v. Dairyland Creamery Co. (S.D. Sup. Ct.), 17 N.W. (2d) 262. See also Pyramid Motor Freight Corp. v. Ispass 330 U.S. 695.) Activities which do not directly affect such safety of operation include those performed by employees whose jobs are confined to such work as that of dispatchers, carpenters, tarpaulin tailors vehicle painters, or servicemen who do nothing but oil, gas, grease, or wash the motor vehicles. (Ex parte Nos. MC-2 and MC-3, 28 M.C.C. 125, 132, 133, 135) To these may be added activities such as filling radiators, checking batteries, and the usual work of such employees as stockroom personnel, watchmen, porters, and garage employees performing menial nondiscretionary tasks or disassembling work. Employees whose work is confined to such ``nonsafety'' activities are not within the exemption, even though the proper performance of their work may have an indirect effect on the safety of operation of the motor vehicles on the highways. (Morris v. McComb, 332 U.S. 422; Campbell v. Riss & Co. (W.D. Mo.), 5 Labor Cases,par. 61,092 (dispatcher); McDuffie v. Hayes Freight Lines, 71 F. Supp. 755 (work of janitor and caretaker, carpentry work, body building, removing paint, preparing for repainting, and painting); Walling v. Silver Fleet Motor Express, 67 F. Supp. 846 (body building, construction work, painting and lettering); Hutchinson v. Barry, 50 F. Supp. 292 (washing vehicles); Walling v. Palmer, 67 F. Supp. 12 (putting water in radiators and batteries, oil and gas in vehicles, and washing vehicles); Anuchick v. Transamerican Freight Lines, 46 F. Supp. 861 (body builders, tarpaulin worker, stockroom boy, night watchman, porter); Bumpus v. Continental Baking Co. (W.D. Tenn.), 1 Wage Hour Cases 920 (painter), reversed on other grounds 124 F. (2d) 549; Green v. Riss & Co., 45 F. Supp. 648 (night watchman and gas pump attendant); Walling v. Burlington Transp. Co. (D. Nebr.), 9 Labor Cases, par. 62,576 (body builders); Keegan v. Ruppert (S.D. N.Y.), 7 Labor Cases, par. 61,726 (greasing and washing); Walling v. East Texas Freight Lines (N.D. Tex.), 8 Labor Cases, par. 62,083 (Menial tasks); Collier v. Acme Freight Lines, unreported (S.D. Fla., Oct. 1943) (same); Potashnik Local TruckSystem v. Archer (Ark. Sup. Ct.). 179 S.W. (2d) 696 (checking trucks in and out and acting as night dispatcher, among other duties); Overnight Motor Corp. v. Missel, 316 U.S. 572 (rate clerk with part-time duties as dispatcher).) The same has been held true of employees whose activities are confined to construction work, manufacture or rebuilding of truck, bus, or trailer bodies, and other duties which are concerned with the safe carriage of the contents of the vehicle rather than directly with the safety of operation on the public highways of the motor vehicle itself (Anuchick v. Trans american Freight Lines, 46 F. Supp. 816; Walling v. Silver Fleet Motor Express, 67 F. Supp. 846; McDuffie v. Hayes Freight Lines 71 F. Supp. 755; Walling v. Burlington Transp. Co. (D. Nebr.), 9 Labor Cases, par. 62,576. Compare Colbeck v. Dairyland Creamery Co. (S.D. Sup. Ct.) 17 N.W. (2d) 262 with Ex parte No. MC-40 (Sub. No. 2), 88 M.C.C. 710.) (2) The distinction between direct and indirect effects on safety of operation is exemplified by the comments in rejecting the contention in Ex parte Nos. MC-2 and MC-3, 28 M.C.C. 125, 135, that the activities of dispatchers directly affect safety of operation. It was stated: ``It is contended that if a dispatcher by an error in judgment assigns a vehicle of insufficient size and weight-carrying capacity to transport the load, or calls a driver to duty who is sick, fatigued, or otherwise not in condition to operate the vehicle, or requires or permits the vehicle to depart when the roads are icy and the country to be traversed is hilly, an accident may result. While this may be true, it is clear that such errors in judgment are not the proximate causes of such accidents, and the dispatchers engage in no activities which directly affect the safety of operation of motor vehicles in interstate or foreign commerce.'' [[Page 598]] (3) Similarly, the exemption has been held inapplicable to mechanics repairing and rebuilding parts, batteries, and tires removed from vehicles where a direct causal connection between their work and the safe operation of motor vehicles on the highways is lacking because they do no actual work on the vehicles themselves and entirely different employees have the exclusive responsibility for determining whether the products of their work are suitable for use, and for the correct installation of such parts, on the vehicles. (Keeling v. Huber & Huber Motor Express, 57 F. Supp. 617; Walling v. Huber & Huber Motor Express, 67 F. Supp. 855) Mechanical work on motor vehicles of a carrier which is performed in order to make the vehicles conform to technical legal requirements rather than to prevent accidents on the highways has not been regarded by the courts as work directly affecting ``safety ofoperation.'' (Kentucky Transport Co. v. Drake (Ky. Ct. App.), 182 S.W. (2d) 960; Anuchick v. Transamerican Freight Lines, 46 F. Supp. 861; Yellow Transit Freight Lines Inc. v. Balsen 320 F. (2d) 495 (C.A. 8)) And it is clear that no mechanical work on motor vehicles can be considered to affect safety of operation of such vehicles in interstate or foreign commerce if the vehicles are never in fact used in transportation in such commerce on the public highways. (Baker v. Sharpless Hendler Ice Cream Co. (E.D. Pa.), 10 Labor Cases, par. 62,956)